Continental Fireplaces CBL36NTE Manuals

EN FR PG 59 W415-1443 / C / 06.06.16 INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE. CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE. NEVER LEAVE CHILDREN OR OTHER AT RISK INDIVIDUALS ALONE WITH THE APPLIANCE. INSTALLATION AND OPERATING INSTRUCTIONS Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 0G8 Canada / 103 Miller Drive, Crittenden, Kentucky, USA, 41030 Phone (705)721-1212 • Fax (705)722-9081 • www.continentalfi replaces.com • ask@continentalfi re.on.ca 1.24D $10.00 CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS. SAFETY INFORMATION ! WARNING - Do not store or use gasoline or other fl ammable vapors and liquids in the vicinity of this or any other appliance. - WHAT TO DO IF YOU SMELL GAS: • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbour’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fi re department. - Installation and service must be performed by a qualifi ed installer, service agency or the supplier. If the information in these instructions are not followed exactly, a fi re or explosion may result causing property damage, personal injury or loss of life. HOT GLASS WILL CAUSE BURNS. DO NOT TOUCH GLASS UNTIL COOLED. NEVER ALLOW CHILDREN TO TOUCH GLASS. ! DANGER A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed for the protection of children and other at-risk individuals. This appliance may be installed in an aftermarket, permanently located, manufactured home (USA only) or mobile home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certifi ed kit is used. Decorative Product: Not for use as a heating appliance. CONFORMS TO AMERICAN NATIONAL STANDARDS: ANSI Z21.50, CERTIFIED TO CANADIAN CSA 2.22 FOR VENTED GAS FIREPLACES. CBL36PTE PROPANE GAS MODEL CBL36NTE NATURAL GAS MODEL SAFETY BARRIER 2 W415-1443 / C / 06.06.16 EN 1.0 INSTALLATION OVERVIEW 3 2.0 INTRODUCTION 4 2.1 DIMENSIONS 5 2.2 GENERAL INSTRUCTIONS 6 2.3 GENERAL INFORMATION 7 2.4 RATING PLATE INFORMATION 8 3.0 VENTING 9 3.1 VENTING LENGTHS AND COMPONENTS 10 3.2 TYPICAL VENT INSTALLATION 11 3.3 SPECIAL VENT INSTALLATIONS 12 3.3.1 PERISCOPE TERMINATION 12 3.4 MINIMUM AIR TERMINAL LOCATION CLEARANCES 13 3.5 VENTING APPLICATION FLOW CHART 14 3.6 DEFINITIONS 14 3.7 ELBOW VENT LENGTH VALUES 14 3.8 TOP EXIT HORIZONTAL TERMINATION 15 3.9 TOP EXIT VERTICAL TERMINATION 17 3.10 COLLAR INSTALLATION 19 4.0 INSTALLATION 20 4.1 WALL AND CEILING PROTECTION 20 4.1.1 HORIZONTAL INSTALLATION 21 4.1.2 VERTICAL INSTALLATION 21 4.2 USING FLEXIBLE VENT COMPONENTS 22 4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 22 4.2.2 VERTICAL AIR TERMINAL INSTALLATION 23 4.2.3 APPLIANCE VENT CONNECTION 24 4.3 USING RIGID VENT COMPONENTS 24 4.3.1 HORIZONTAL AIR TERMINAL INSTALLATION 24 4.3.2 VERTICAL AIR TERMINAL INSTALLATION 25 4.3.3 RESTRICTING VERTICAL VENTS 26 4.4 VERTICAL THROUGH EXISTING CHIMNEY 27 4.6 MOBILE HOME INSTALLATION 28 4.5 GAS INSTALLATION 28 4.7 OPTIONAL WALL SWITCH 29 5.0 FRAMING 30 5.1 MINIMUM FRAMING DIMENSIONS 31 5.2 NAILING TAB INSTALLATION 32 5.3 MINIMUM ENCLOSURE CLEARANCES 33 5.4 INSTALLATION OF NON-COMBUSTIBLE BOARD 34 5.5 RECESSED INSTALLATION 35 5.6 MINIMUM COMBUSTIBLE MANTEL CLEARANCES 36 6.0 FINISHING 37 6.1 SAFETY SCREEN & DOOR REMOVAL / INSTALLATION 37 6.2 GLASS MEDIA INSTALLATION 38 6.3 CONTROL COVER INSTALLATIONS 39 6.4 LOGO PLACEMENT 39 6.5 BATTERY BACK-UP INSTALLATION 40 6.6 OPTIONAL BLOWER INSTALLATION 41 6.7 WIRING DIAGRAM (ELECTRONIC) 42 7.0 OPERATION 43 8.0 ADJUSTMENT 44 8.1 PILOT BURNER ADJUSTMENT 44 8.2 VENTURI ADJUSTMENT 44 8.3 FLAME CHARACTERISTICS 45 8.4 OPTIONAL ANTI CONDENSATION SWITCH 45 9.0 MAINTENANCE 46 9.1 ANNUAL MAINTENANCE 47 9.2 DOOR GLASS REPLACEMENT 48 9.3 CARE OF GLASS 48 10.0 REPLACEMENTS 49 10.1 OVERVIEW 50 10.2 VALVE TRAIN ASSEMBLY 51 11.0 ACCESSORIES 52 12.0 TROUBLESHOOTING 53 13.0 WARRANTY 56 14.0 SERVICE HISTORY 57 NOTE: Changes, other than editorial, are denoted by a vertical line in the margin. TABLE OF CONTENTS NOTE: The camera icon indicates video tutorials are available as additional reference, visit http://mynapoleon.napoleonproducts.com/download/index/44/1 3 W415-1443 / C / 06.06.16 EN See the section “MINIMUM ENCLOSURE CLEARANCES” for drywall (or other combus- tible material). See the section “MINIMUM MANTEL CLEARANCES”. Side Wall See the section “FRAMING”. See the section “VENTING” and “INSTALLATION”. See the section “RATING PLATE INFORMATION”. SAFETY BARRIER See the section “MINIMUM FRAMING DIMENSIONS”. 1.0 INSTALLATION OVERVIEW Batteries must be disposed of according to the local laws and regulations. Some batteries may be recycled, and may be accepted for disposal at your local recycling center. Check with your municipality for recycling instructions. 4 W415-1443 / C / 06.06.16 EN 2.0 INTRODUCTION 3.2C ! WARNING • THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED. • ANY CHANGES OR ALTERATIONS TO THIS APPLIANCE OR ITS CONTROLS CAN BE DANGEROUS AND IS PROHIBITED. • Do not operate appliance before reading and understanding operating instructions. Failure to operate appliance according to operating instructions could cause fi re or injury. • Risk of fi re or asphyxiation do not operate appliance with fi xed glass removed. • Do not connect 110 volts to the control valve. • Risk of burns. The appliance should be turned off and cooled before servicing. • Do not install damaged, incomplete or substitute components. • Risk of cuts and abrasions. Wear protective gloves and safety glasses during installation. Sheet metal edges may be sharp. • Do not burn wood or other materials in this appliance. • Children and adults should be alerted to the hazards of high surface temperature and should stay away to avoid burns or clothing ignition. • Young children should be carefully supervised when they are in the same room as the appliance. Toddlers, young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individuals in the house. To restrict access to an appliance, install an adjustable safety gate to keep toddlers, young children and other at risk individuals out of the room and away from hot surfaces. • Clothing or other fl ammable material should not be placed on or near the appliance. • Due to high temperatures, the appliance should be located out of traffi c and away from furniture and draperies. • Ensure you have incorporated adequate safety measure to protect infants/toddlers from touching hot surfaces. • Even after the appliance is out, the glass and/or screen will remain hot for an extended period of time. • Check with your local hearth specialty dealer for safety screens and hearth guards to protect children from hot surfaces. These screens and guards must be fastened to the fl oor. • Any safety screen, guard or barrier removed for servicing the appliance, must be replaced prior to operating the appliance. • The appliance is a vented gas-fi red appliance. Do not burn wood or other materials in the appliance • It is imperative that the control compartments, burners and circulating blower and its passageway in the appliance and venting system are kept clean. The appliance and its venting system should be inspected before use and at least annually by a qualifi ed service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. The appliance area must be kept clear and free from combustible materials, gasoline and other fl ammable vapors and liquids. • Under no circumstances should this appliance be modifi ed. • This appliance must not be connected to a chimney fl ue pipe serving a separate solid fuel burning appliance. • Do not use this appliance if any part has been under water. Immediately call a qualifi ed service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water. • Do not operate the appliance with the glass door removed, cracked or broken. Replacement of the glass should be done by a licensed or qualifi ed service person. • Do not strike or slam shut the appliance glass door. • When equipped with pressure relief doors, they must be kept closed while the appliance is operating to prevent exhaust fumes containing carbon monoxide, from entering into the home. Temperatures of the exhaust escaping through these openings can also cause the surrounding combustible materials to overheat and catch fi re. • Only doors / optional fronts certifi ed with the appliance are to be installed on the appliance. • Keep the packaging material out of reach of children and dispose of the material in a safe manner. As with all plastic bags, these are not toys and should be kept away from children and infants. • As with any combustion appliance, we recommend having your appliance regularly inspected and serviced as well as having a Carbon Monoxide Detector installed in the same area to defend you and your family against Carbon Monoxide. • Ensure clearances to combustibles are maintained when building a mantel or shelves above the appliance. Elevated temperatures on the wall or in the air above the appliance can cause melting, discolouration or damage of decorations, a T.V. or other electronic components. • A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed. • If the barrier becomes damaged, the barrier shall be replaced with the manufacturer’s barrier for this appliance. • Installation and repair should be done by a qualifi ed service person. The appliance should be inspected before use and at least annually by a professional service person. More frequent cleaning may be required due to excessive lint from carpeting, bedding material, etc. It is imperative that control compartments, burners and circulating air passageways of the appliance be kept clean.