Delta UPS602N2004N035 Manuals

www.deltapowersolutions.com 1/ 4 Delta UPS - Amplon Family N Series, Single Phase 6/ 10 kVA Maintenance Bypass Box for Single UPS & Parallel UPSs Installation & Operation Quick Guide ENGLISH Product Introduction 1 The Maintenance Bypass Box is designed to operate in conjunction with your Delta N series 6kVA/ 10kVA UPS. It ensures that your connected critical load continues to be powered from the input supply during UPS maintenance or during the unlikely event of a UPS failure. Important Safety Instructions 2 y y Only qualified service personnel can perform installation and maintenance of the Main- tenance Bypass Box. y y The Maintenance Bypass Box must operate in conjunction with Delta N series 6kVA/ 10kVA UPS. Please refer to the following table. Maintenance Bypass Box Model PDB1511A530035 (for single UPS application) PDB1512A510035 (for parallel UPSs application) Applicable Delta N series UPS Model UPS103N2002N009 UPS103N2004N0B0 UPS103N2004N0BA UPS103N2004N035 UPS602N2002N009 UPS602N2004N0B0 UPS602N2004N0BA UPS602N2004N035 UPS103N2004N0B0 UPS103N2004N0BA UPS103N2004N035 UPS602N2004N0B0 UPS602N2004N0BA UPS602N2004N035 y y Before installation of the Maintenance Bypass Box, please completely turn off the UPS and cut off the input power and battery power (if applicable). y y Failure to properly install the Maintenance Bypass Box may result in severe damage to your UPS or load equipment. y y Please install the Maintenance Bypass Box in an indoor temperature controlled environ- ment that is free of conductive contaminants. y y Do not operate the unit in extremely dusty and/ or unclean areas, locations near heating devices, water or excessive humidity, or where the unit is exposed to direct sunlight. y y Select a location where provides good air circulation for the unit at all times. y y Properly route power cords so they cannot be walked on or damaged. y y The Maintenance Bypass Box must be well grounded due to a possible risk of current leakage. y y The Maintenance Bypass Box is not intended for use in direct patient care or in life sup- port applications. Package List 3 y y Model PDB1511A530035_ Maintenance Bypass Box for Single UPS Application 2 1 8 5 3 4 9 10 6 7 No. Item Q'ty 1 CU Terminal (Type A) 4 PCS 2 CU Terminal (Type B) 4 PCS 3 Terminal Holder 2 PCS 4 Screw for Fastener 8 PCS 5 Fastener (Type A) 4 PCS 6 Wire 1 1 PCS 7 Wire 2 1 PCS 8 Cable Tie 6 PCS 9 Screw for Terminal Holder 2 PCS 10 RS-232 Cable 1 PCS y y Model PDB1512A510035_ Maintenance Bypass Box for Parallel UPSs Application 2 6 5 1 11 10 3 13 12 7 4 8 9 No. Item Q'ty 1 Heat Shrink Tube 12 PCS 2 CU Terminal (Type B) 4 PCS 3 CU Terminal (Type C) 6 PCS 4 Terminal Holder 4 PCS 5 Screw for Fastener 12 PCS 6 Fastener (Type A) 4 PCS 7 Fastener (Type B) 1 PCS 8 Wire 1 2 PCS 9 Wire 2 2 PCS 10 Cable Tie 6 PCS 11 Cable Gland 2 PCS 12 Screw for Terminal Holder 4 PCS 13 Parallel Cable 1 PCS NOTE: 1. If there is any damage or anything missing, please immediately contact the dealer from whom you purchased the unit. 2. If the Maintenance Bypass Box needs to be returned, carefully repack the Maintenance Bypass Box and all of the accessories using the original packing material that came with the unit. Standard Compliance 4 y y IEC y y EN62040-1 How to Remove the Front Panel 5 输出断路器 OUTPUT BREAKER ON OFF 旁路开关BYPASS SWITCH 旁路断路器 UPS1 输出断路器 UPS1 OUTPUT BREAKER UPS2 输出断路器 UPS2 OUTPUT BREAKER OFF ON OFF ON BYPASS BREAKER 警告: 开起此盖板时,会即刻关闭逆变器输出.非授 权合格人员,严禁开起. W A R N IN G : O P E N IN G T H I S C O V E R P L A TE W ILL C A U S E IN V E R T E R S H U TD O W N . O N LY AU TH O R I ZE D S E R V IC E P E R S O N N E L C A N O P E N A N D O P E R A TE IT. 警告: 开起此盖板时,会即刻关闭逆变器输出.非授 权合格人员,严禁开起. W A R N IN G : O P E N IN G T H I S C O V E R P L A TE W ILL C A U S E IN V E R T E R S H U TD O W N . O N LY AU TH O R I ZE D S E R V IC E P E R S O N N E L C A N O P E N A N D O P E R A TE IT. Remove the Front Panel Pull Pull Remove the Front Panel PDB1512A510035 PDB1511A530035 Front View after Front Panel Removal 6 y y PDB1511A530035 OFF ON BYPASS SWITCH 旁路开关 输出断路器 OUTPUT BREAKER 警告: 开起此盖板时, 会即刻关闭逆变器输出. 非授 权合格人员, 严禁开起. W A R N IN G : O P E N I N G T H I S C O V E R P L A T E W I L L C A U S E I N V E R T E R S H U T D O W N . O N L Y A U T H O R I Z E D S E R V I C E P E R S O N N E L C A N O P E N A N D O P E R A T E I T . 2 1 5 4 3 No. Item 1 Latch (for fastening the front panel) 2 Latch (for fastening the front panel) 3 Bypass Switch (please remove the cover’s screw shown in the figure above to see the bypass switch) 4 Output Breaker 5 Latch (for fastening the front panel) y y PDB1512A510035 旁路断路器 UPS2 输出断路器 UPS2 OUTPUT BREAKER UPS1 输出断路器 UPS1 OUTPUT BREAKER BYPASS BREAKER OFF ON OFF ON 警告: 开起此盖板时, 会即刻关闭逆变器输出. 非 授权合格人员, 严禁开起. W A R N IN G : OPENING THIS COVER PLATE WILL CAUSE INVERTER SHUTDOWN. ONLY AUTHORIZED SERVICE PERSONNEL CAN OPEN AND OPERATE IT. 1 2 3 4 5 6 No. Item 1 Latch (for fastening the front panel) 2 Latch (for fastening the front panel) 3 UPS2 Output Breaker Continue to the Next Page  5013246101

www.deltapowersolutions.com Delta UPS - Amplon Family User Manual The power behind competitiveness N Series, Single Phase 6/ 10 kVA ON OFF SETUP