lancer 500 Series Manuals

2 pdf manual(s) lancer 500 Series for free download (Document Types: Installation and service manual, Operation manual)

lancer 500 Series Installation and service manual [PDF] (16 pages)

  • Identifier: id-1262347
  • Brand: lancer
  • Device: 500 Series Dispenser
  • Type: PDF
  • Key Aspects: Routine Functionality Testing, Critical Operational Precautions, Technical Support and Resource Links
  • UPD Date: 01.08.2026
  • Source File: 1276194.pdf
  • Pages: 16
  • Description: User instructions for the lancer 500 Series.
Pages Preview:
  • TABLE OF CONTENTS SPECIFICATIONS...................................................................................................................................COVER TABLE OF CONTENTS .....................................................................................................................................1 1. INSTALLATION ..........................................................................................................................
  • 1.2 UNPACKING A. Remove cup rest by lifting out. B. Remove splash plate by pulling forward at the bottom. Drip tray can be removed before removing splash plate. C. Remove drip tray by lifting out. D. Remove shipping base. DO NOT LAY UNIT ON ITS SIDE OR BACK. DO NOT USE DRIP TRAY FRAME FOR A HANDLE. NOTE If unit is to be transported, it is advisable to leave unit secured to plywood shipping base. E. Inspect unit for concealed damage. If damage exists, n
  • B. Mark both ends of product and water lines and route to dispenser. Flush lines to be sure each is clean. Failure to do so may result in clogging of valve(s), resulting in improper operation. Connect lines to dispenser and secure using Oetiker clamps. C. Route drain tube to dispenser. D. Connect drain tube to drip tray and install on dispenser. E. Turn on water supply. F. Open all dispenser valves until air is bled from system. G. Actuate valve until a
  • phenolpthalein shows that the rinse water is free of residual detergent. F. Fill the lines with a low pH (7.0) chlorine solution containing at least 50 parts per million (PPM) (50 mg/L) available chlorine. Make sure that lines are completely filled and allow to stand for ten (10) minutes. G. Reconnect syrup containers and ready Unit for operation. WARNING REMOVE SANITIZING SOLUTION FROM DISPENSER AS INSTRUCTED. RESIDUAL SANITIZING SOLUTION LEFT IN SYSTEM
  • 4.5 Insufficient syrup flow. A. Insufficient CO2 pressure to A. Adjust CO2 pressure to 80 PSI BIB pumps. (5.5 bar) [minimum 70 PSI (4.8 bar)] for BIB pumps. B. Shutoff on mounting block not B. Open shutoff fully. fully open. C. Foreign debris in syrup flow C. Remove syrup flow control from control. upper body and clean out any foreign material to ensure smooth free spool movement. 4.6 Erratic ratio. A. Incoming water and/or syrup A. Check pressure and adju
Document Preview & Text Transcription (Main Page)
Click to expand and read text
INSTALLATION AND SERVICE MANUAL FOR COUNTER ELECTRIC DISPENSER LANCER SERIES 500 REV: 04/20/00 P.N. 28–0449 This manual is an initial issue FAX ENGINEERING: • 210-310-7096 "Lancer" is the registered trademark of Lancer • Copyright — 2000 by Lancer, all rights reserved. SPECIFICATIONS DIMENSION Width 10 3/8 inches (264 mm) Depth 25 1/4 inches (641 mm) Height (without legs) 22 15/16 inches (583 mm) WEIGHT Shipping 108 pounds (49.0 kg) Empty 89 pounds (40.4 kg) Operating 125 pounds (55.4 kg) WATER REQUIREMENTS CAUTION IF WATER SOURCE EXCEEDS 60 PSIG (4.22 KG/CM2), A RECOMMENDED WATER REGULATOR ASSEMBLY (PN 18-0253) MUST BE USED TO LIMIT WATER PRESSURE TO 60 PSIG (4.22 KG/CM2). FAILURE TO USE REGULATOR WILL RESULT IN IMPROPER PERFORMANCE OF DISPENSER. Minimum flowing pressure of 35 PSIG (2.46 kg/cm2, 2.41 BAR) Maximum static pressure of 60 PSIG (4.22 kg/cm2, 4.14 BAR) CARBON DIOXIDE (CO2) REQUIREMENTS Minimum pressure of 70 PSIG (4.92 kg/cm2, 4.83 BAR) Maximum pressure of 80 PSIG (5.62 kg/cm2, 5.52 BAR) ICE BANK WEIGHT 16 pounds (17.26 kg) WATER BATH CAPACITY 5.1 gallons (19.3 liters) COMPRESSOR ¼ HP Tecumseh, 115V/60Hz AGITATOR MOTOR 15W, 115V CONDENSER FAN MOTOR 9W, 115V ICE BANK CONTROL Lancer Electronic Ice Bank Control TRANSFORMER Basler, 115V (Primary)/24V (Secondary) Optional 230V/50Hz and 240V/60Hz systems available. DRINK CAPACITY 57 – 12 ounce drinks under 40°F (4.4°C) at four (4) drinks per minute with 75°F (23.9°C) ambient, inlet water, and inlet syrup. Please refer to the Lancer web site (www.lancercorp.com) for information relating to Lancer Installation and Service Manuals, Instruction Sheets, Technical Bulletins, Service Bulletins, etc. 6655 LANCER BLVD. • SAN ANTONIO, TEXAS 78219 USA • (210) 310-7000 FAX SALES • NORTH AMERICA – 210-310-7245 • INTERNATIONAL SALES – 210-310-7242 • CUSTOMER SERVICE – 210-310-7242 • • LATIN AMERICA – 210-310-7245 • EUROPE – 32-2-755-2399 • PACIFIC – 61-8-8268-1978 •

lancer 500 Series Operation manual [PDF] (26 pages)

  • Identifier: id-992112
  • Brand: lancer
  • Device: 500 Series Dispenser
  • Type: PDF
  • Key Aspects: Periodic Inspection Checklists, Step-by-Step Assembly Procedures, Additional Modules and Accessories Guide
  • UPD Date: 21.04.2026
  • Source File: 1166376.pdf
  • Pages: 26
  • Description: Instruction booklet for the lancer 500 Series.
Pages Preview:
  • ABOUT THIS MANUAL This booklet is an integral and essential part of the product and should be handed over to the operator after the instal- lation and preserved for any further consultation that may be necessary. Please read carefully the guidelines and warn- ings contained herein as they are intended to provide the user with essential information for the continued safe use and maintenance of the product. In addition, it provides GUIDACE ONLY to the user o
  • 3 4.11 COMPRESSOR DOES NOT START (NO HUM), BUT CONDENSOR FAN MOTOR RUNS..................................................................................................................................18 4.12 COMPRESSOR STARTS AND CONTINUES TO RUN UNBTIL FREEZE UP AND WILL NOT CUT OFF....................................................................................................................18 4.13 COMPRESSOR DOES NOT START BUT HUMS..............
  • TOUCHPOINT SPECIFICATIONS DIMENSIONS Width: 10 3/8 in (264 mm) Depth: 25 1/4 in (641 mm) Height (w/out legs): 22 15/16 in (583 mm) SPACE REQUIRED Left Side: 4 in (101.6 mm) Right side: 4 in (101.6 mm) Back: 4 in (101.6 mm) Top: 8 in (203.2 mm) ELECTRICAL 115VAC/60Hz/4.3AMPs 230-240VAC/50-60Hz/2.6AMPs WEIGHT Empty: 89 lbs (40.4 kg) Operating: 125 lbs (55.4 kg) Shipping: 108 lbs (49.0 kg) ICE Capacity: 16 lbs (17.26 kg) FITTINGS Water for carbonator inlet: 3
  • PRE-INSTALLATION CHECKLIST BEFORE GETTING STARTED Each unit is tested under operating conditions and is thoroughly inspected before shipment. At the time of shipment, the carrier accepts responsibility for the unit. Upon receiv- ing the unit, carefully inspect the carton for visible damage. If damage exists, have the car- rier note the damage on the freight bill and file a claim with carrier. Responsibility for dam- age to the dispenser lies with the carri
  • WARNING/ADVERTENCIA/AVERTISSEMENT ! The dispenser is for indoor use only. This appliance is intended for use in commercial applications such as res- taurants, stores or similar. This unit is not a toy. It should not be used by children or infirm persons without supervi- sion. This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have bee
Document Preview & Text Transcription (Main Page)
Click to expand and read text
LANCER CORP 6655 Lancer Blvd. San Antonio, Texas 78219 To order parts, call Customer Service: 800-729-1500 Warranty/Technical Support: 800-729-1550 Email: [email protected] www.lancercorp.com Manual PN: 28-0063/06 NOVEMBER 10, 2014 FOR QUALIFIED INSTALLER ONLY Counter Electric Dispenser Lancer Series 500 Operation Manual PN: 28-0063/06 ISO 9001:2000 Quality System Certified “Lancer” is the registered trademark of Lancer © 2013 by Lancer, all rights reserved.

500 Series: Related Instructions

Twin Pour
lancer Twin Pour
30.05.2026 34 pages

Twin Pour “Lancer” is the registered trademark of Lancer © 2019 by Lancer, all rights reserved. ® FS44 Lancer Corporation 6655 Lancer Blvd. San Antonio, T Operating handbook for the lancer Twin Pour Dispenser. It describes step-by-step component replacement, system setup, service instructions, startup procedures.

4400 Series
lancer 4400 Series
03.08.2026 12 pages

Ice Dispenser 22” - Model 4400 LANCER INSTALLATION GUIDE ABOUT THIS MANUAL This booklet is an integral and essential part of the product and should be handed Technical reference manual for the lancer 4400 Series Dispenser. This documentation details procedures for hardware instructions, basic operation, daily usage.

2300 Series
lancer 2300 Series
26.04.2026 34 pages

Lancer Corp. 6655 Lancer Blvd. San Antonio, Texas 78219 800-729-1500 Technical Support/Warranty: 800-729-1550 [email protected] lancercorp.com Manual PN: User instructions for the lancer 2300 Series Dispenser. The document elaborates on device functions and troubleshooting tips, device operation tips, maintenance schedule, system parameters.

21000165
lancer 21000165
05.04.2026 13 pages

www.lancerbeverage.com Installation, Operation & Service Manual VERSAPOUR VALVES Device maintenance guide for the lancer 21000165 Control Unit. It provides technical information on operating instructions, operational procedures, troubleshooting, connectivity setup.

Flavor Select 30
lancer Flavor Select 30
20.06.2026 40 pages

FLAVOR SELECT 30 (FS30) ICE BEVERAGE DISPENSER “Lancer” is the registered trademark of Lancer © 2008 by Lancer, all rights reserved. LANCER 6655 Lancer Blv Device operation guide for the lancer Flavor Select 30 Beverage Dispenser. The documentation includes software installation, operating instructions, usage procedures, user instructions.

STANDARD LEVER
lancer STANDARD LEVER
10.04.2026 28 pages

Lancer Corp. 6655 Lancer Blvd. San Antonio, Texas 78219 800-729-1500 Technical Support/Warranty: 800-729-1550 [email protected] lancercorp.com Manual PN: Detailed operating instructions for the lancer STANDARD LEVER Control Unit. It includes maintenance procedures and technical guidelines, usage procedures, technical assistance, installation steps.

Similar Manuals in the Dispenser Category

Indulge Tuscan F-GN2215
InSinkErator Indulge Tuscan F-GN2215
27.08.2026 1 pages

User guide for the InSinkErator Indulge Tuscan F-GN2215 Garbage Disposal. The documentation includes details on device features, software configuration, functional overview, assembly reference.

625.38575
Kenmore 625.38575
01.08.2026 20 pages

OWNER'S MANUAL MODEL NO. UltraFilter 550 625.385750 Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. If yo Complete usage guide for the Kenmore 625.38575 Water Dispenser. The manual includes instructions for setup instructions, device operation tips, installation steps.

98050
Loctite 98050
23.08.2026 2 pages

Foot Dispenser Item # 98050 With Vacuum ASHCROFT MADE IN U.S.A. 60 90 100 80 70 psi 0 10 20 40 50 30 2 1 3 4 6 5 1 ASHCROFT 100 90 80 70 60 MADE IN U.S.A. psi 0 Professional operation guide for the Loctite 98050 Dispenser. It includes maintenance procedures and firmware updates, software installation, operating conditions, operational procedures.

HWA 6
BRAVILOR BONAMAT HWA 6
20.08.2026 80 pages

www.bravilor.com 1 User manual Mode d’emploi Utilisateur Gebraucher Handbuch Gebruiksaanwijzing Användarmanualen Brukerhåndbok Brugsanvisningen Käyttäjän Instruction and usage manual for the BRAVILOR BONAMAT HWA 6 Water Heater. The manual covers procedures for installation guides, replacement parts, basic operation.