Molift PARTNER 255 Manuals

- a patient lifter from BM03 - English Page 2 of 24 BM03 - English - Molift Partner 230/255 - Rev. G/ 02/2008 IMPORTANT! The patient lifter is only meant to be used by qualified personnel. The manual shall not be handed over, or made available to, any unauthorised third party, wit- hout a prior written consent from Molift AS. Existing laws, conventions and agreements protects all documents. No extract of this do- cumentation can be reproduced, used or trans- ferred without prior written consent from Molift AS. Violation of these regulations may lead to judicial repercussions and economic responsi- bility. Industrial rights are reserved. Molift Group AS Ole Deviksvei 44 0668 OSLO, Norway Teleph:(+47) 40001004 www.molift.com Fax: (+47) 40001008 [email protected] Table of Contents General advice .................................................. 3 Explanation of symbols ............................... 3 Before using the patient lifter ...................... 3 Responsibility .............................................. 3 Safety precautions .......................................... 4 General ....................................................... 4 If defects or faults occur .............................. 4 Lift and transfer ........................................... 4 About the product............................................ 5 Main parts ................................................... 5 Safety devices ............................................. 5 Technical data ................................................... 6 Assembly / disassembly ................................ 7 Assembly and use of charger ...................... 7 Unpacking ................................................... 7 Assembly ..................................................... 7 Checklist before use .................................... 8 Disassembly ................................................ 8 Operation ........................................................... 9 Battery care and charging ........................... 9 Battery capacity ........................................... 9 Operating the hand control .......................... 9 Emergency stop and lowering ..................... 9 Lift and transfer ......................................... 10 Use of spread legs .....................................11 Using lifting slings ......................................11 Lift and movement to and from bed .......... 12 Lift and transfer to and from floor .............. 13 Lift and transfer to and from (wheel) chair 14 Bathing ...................................................... 15 Toileting ..................................................... 16 Accessories .................................................... 17 Lifting sling ................................................ 17 Equipment ....................................................... 18 Suspensions .............................................. 18 Scale ......................................................... 18 Molift Stretcher .......................................... 19 Castor with directional lock ....................... 19 Supporting arms ........................................ 19 Integrated charger ..................................... 19 Maintenance .................................................... 20 Cleaning .................................................... 20 Monthly inspection .................................... 20 Periodic inspection .................................... 20 Service ...................................................... 20 Troubleshooting ......................................... 21 Labelling .................................................... 21 Checklist for periodic inspection ............... 22 Supplier: Page 3 of 24 General advice This user manual contains important safety instruc- tions and information regarding the use of the lifter. Carefully read the manual before using the lifter in order to be familiar in the function and use of the lifter. Explanation of symbols This symbol is used to point out instructions and information related to work place safety where injury may occur if the information is disregarded or ignored. Follow these instruc- tions, be careful and attentive at all times. This symbol indicates important information regarding the use of the equipment. If not taken into consideration, it may lead to dam- age or functional defects to the lifter or other equipment. This symbol indicates important and useful information. If taken into consideration, it will help the operator of the lifter to work ef- ficiently. It may help simplify routines and to explain complicated facts. Before using the patient lifter Before using a patient lifter, the operator must be trained accordingly. Practice lifting a colleague, and be lifted by others. It is important not only to know how to move another person using the lifter, but also how it is to be lifted. Try out and practice using all the relevant slings for the different types of lifter and movement you may encounter. Before lifting a per- son, you should explain the procedure. When using the lifter, it’s also important to use the correct sling and accessories according to: • type of disability • size • weight • type of movement Responsibility Please read these operating instructions carefully before putting the product into operation. We as- sume no liability for damage or malfunctions re- sulting from failure to comply with the instruc- tions. Warranty claims must be made immediately on detecting the defect. Remember to quote the se- rial number. Consumable parts are not subject to the warranty. All technical information, data and instructions for operation contained in these operating instructions were up-to-date at time of print and are compiled on the basis of our experience and to the best of our knowledge. We reserve the right to incorporate tech- nical modifications within the scope of further de- velopment of the product described in this manual. No claims can be derived from the information, il- lustrations or descriptions contained in these in- structions. We assume no liability for any damage or malfunction caused by operating errors, non-com- pliance with these operating instructions or inappro- priate maintenance. We expressly point out that only genuine Molift AS spare parts and accessories ap- proved by us may be used. For safety reasons, the fitting and use of spare parts or accessories, which have not been approved, and unauthorised modifi- cation or conversion of the product, are not permit- ted. Molift AS will accept no liability for damages resulting from such acts. With the exclusion of product liability, Molift AS is liable for faults or omissions on its part within the scope of the warranty obligations stated in the purchase contract. Claims for damages are exclud- ed, irrespective of the legal reason from which such claims are derived. Only documentation belonging to the actual equipment is valid. Any failure to comply with the safety regulations and precautionary measures stated in these operat- ing instructions renders the declaration of conform- ity supplied with the system in accordance with Council Directive (93/42/EEC) concerning medical devices invalid. Page 4 of 24 BM03 - English - Molift Partner 230/255 - Rev. G/ 02/2008 Lift and transfer The patient lifter may tip over if used incor- rectly! Ignorance of warnings and instruc- tions may lead to personnel injury. Read in- structions carefully before attempting to lift anyone. The Molift PARTNER 255 has a Safe Work- ing Load (SWL) on 255 kg / 562 lbs, mean- ing that it is tested and approved for lifting of patients up to 255 kg. The Molift Partner 230 with SWL 230 kg / 507 lbs, lifts patients up to 230 kg. Several factors have to be considered during move- ment of the lifter: • the user shall sit as low as possible facing the lifting column • the user should rest their feet on the chassis Stand to the side of the user when lifting. Ensure that arms and legs are clear of the lift, chair, bed etc. Try to maintain eye contact with the user - this will help the user feel safe and comfortable. Pay close attention to your actions. Ensure that all four loops of the sling are securely fastened to avoid the user slipping or falling Use the drive handles when manouvring the lifter, do not push or pull the patient, suspen- sion or lifting arm. Do not touch the underside of chassis or bet- ween chassis and legs when monouvring the legs. Molift slings shall ONLY be used to lift per- sons. NEVER use the sling to lift and/or move objects of any kind. Molift Partner 230/255 should not be run constantly for more than 10 min during 1 hour. Safety precautions General Before putting a Molift Partner 230/255 into opera- tion, the operator must ensure that the lifter and ac- cessories are in good working order, especially with regards to safety. The lifter must be taken out of service immediately, or not returned to use, if faults and/or irregularities that may have influence on the safety are discovered. A Molift Partner 230/255 shall only be used when all safety devices and equipment is in place and ful- ly operational. The lifter is designed for indoor use in room temperature, +10 to +40 °C. This should be taken into consideration when transporting the lifter, and therefore keeping it in a tem- perate part of the vehicle. Alternatively, the lifter must rest in a temperate room until the equipment has achieved proper working tem- perature. The lifter has an expected lifetime of 10 years or 30 000 lifts with max load (SWL), when all recommended service is performed. If defects or faults occur The lifter must be switched off immediately if one of the following conditions occur; • damage to electrical devices or cables, or damage to parts of electrical insulation • damage or failure on safety devices If the lifting movement does not start when the corresponding button is pressed, please consult the fault finding table in the mainte- nance chapter to locate the fault. Injury to personnel or equipment may occur if Molift Partner 230/255 is used in an incorrect manner and if: • covers are removed by unauthorised personnel • used incorrectly • insufficient maintenance • load exceeds maximum limit, stated as SWL in this manual and on the lifter. • unauthorised repair of electrical devices or cables

- a patient lifter from TM03101 Molift Partner 255 Engelsk Page 2 of 32 TM03101 Molift Partner 255 Engelsk - Rev. F/ 11/2010 Table of content General advice........................................................ 3 Explanation of symbols.................................... 3 Caution............................................................... 3 Responsibility.................................................... 3 Technical description.......................................... 4 Main parts.......................................................... 4 Chassis with legs.............................................. 4 Column with battery holder............................. 4 Arm with suspension and rubber protection.4 Hand control unit.............................................. 4 Charger and battery......................................... 4 Technical data......................................................... 5 Service....................................................................... 6 Service............................................................... 6 Cleaning............................................................. 6 Troubleshooting................................................ 6 Maintenance............................................................ 7 Changing of the suspension........................... 7 Repair of column.............................................. 7 Removing and lubricating of the brake........... 7 Removing the column sealing........................ 7 Removing the sealing guides......................... 8 Removing the trolley with wheels................... 8 Mounting of trolley and wheels....................... 8 Mounting a new sealing................................. 8 Mounting the brake........................................ 8 Changing parts in chassis............................... 9 Removing the leg spreading motor................ 9 Mounting the leg spreading motor................ 10 Removing the lifting motor .......................... 10 Castors............................................................. 10 Rear castors................................................. 10 Front castors................................................ 10 Main circuit board............................................11 Replacing emergency stop button.................11 Mounting the circuit board.............................11 Labelling...........................................................11 Finishing the job.................................................. 12 Safety control.................................................. 12 Logging............................................................ 12 Inspection Diagram after Service and Repair.............................................................. 13 Appendix A............................................................. 14 Main parts........................................................ 15 Appendix B............................................................. 16 Chassie with legs............................................17 Appendix C............................................................. 18 Chassis and motors....................................... 19 Appendix D............................................................. 20 Column assembly........................................... 21 Appendix E............................................................. 22 Battery holder assembly................................ 23 Appendix F............................................................. 24 Lifting arm........................................................ 25 Appendix G............................................................ 26 Suspensions.................................................... 27 Appendix H............................................................. 28 Equipment....................................................... 29 Low leg............................................................. 29 Supporting arms............................................. 29 Appendix I.............................................................. 30 Electrical diagram........................................... 30 IMPORTANT! The patient lifter is only meant to be used by qualified personnel. The manual shall not be handed over, or made available to, any unauthorised third party, wit- hout a prior written consent from Molift Group AS. Existing laws, conventions and agreements protects all documents. No extract of this do- cumentation can be reproduced, used or trans- ferred without prior written consent from Molift Group AS. Violation of these regulations may lead to judicial repercussions and economic responsibility. Industrial rights are reserved. Molift Group AS Ole Deviksvei 44 0668 OSLO, Norway IMPORTANT! The patient lifter is only meant to be used by qualified personnel. The manual shall not be handed over, or made available to, any unauthorised third party, wit- hout a prior written consent from Molift Group AS. Existing laws, conventions and agreements protects all documents. No extract of this do- cumentation can be reproduced, used or trans- ferred without prior written consent from Molift Group AS. Violation of these regulations may lead to judicial repercussions and economic responsibility. Industrial rights are reserved. Molift Group AS Ole Deviksvei 44 0668 OSLO, Norway Teleph: (+47) 40001004 www.molift.com Fax: (+47) 40001008 [email protected] Page 3 of 32 General advice This manual contains important safety instruc- tions and information regarding the repair and maintenance of the lifter. Carefully read the manual before using the lifter in order to be fa- miliar in the function and use of the lifter. Explanation of symbols Locations in diagrams are reffered as follos: C 28 C28 refers to Appendix A, position 1. This symbol is used to point out instruc- tions and information related to work place safety where injury may occur if the information is disregarded or ignored. Follow these instructions, be careful and attentive at all times. This symbol indicates important informa- tion regarding the use of the equipment. If not taken into consideration, it may lead to damage or functional defects to the lifter or other equipment. This symbol indicates important and use- ful information. If taken into considera- tion, it will help the operator of the lifter to work efficiently. It may help simplify rou- tines and to explain complicated facts. Caution Heavy, long and/or sharp objects will have to be handled when repairing the lifter. When dis- assembling and assembling the lifter you may also find that the stability of the lifter may be re- duced, increasing the risk of toppling the lifter or parts falling down. Therefore, use general caution when per- forming maintenance and repairs. Read the user manual for operating in- structions and safety precautions. Responsibility Please read these operating instructions care- fully before putting the product into operation. We assume no liability for damage or malfunc- tions resulting from failure to comply with the in- structions. Warranty claims must be made im- mediately on detecting the defect. Remember to quote the serial number. Consumable parts are not subject to the warranty. All technical information, data and instructions for operation contained in these operating in- structions were up-to-date at time of print and are compiled on the basis of our experience and to the best of our knowledge. We reserve the right to incorporate technical modifications within the scope of further development of the product described in this manual. No claims can be derived from the information, illustra- tions or descriptions contained in these instruc- tions. We assume no liability for any damage or malfunction caused by operating errors, non- compliance with these operating instructions or inappropriate maintenance. We expressly point out that only genuine Molift AS spare parts and accessories approved by us may be used. For safety reasons, the fitting and use of spare parts or accessories, which have not been ap- proved, and unauthorised modification or con- version of the product, are not permitted. Molift AS will accept no liability for damages resulting from such acts. With the exclusion of product liability, Molift AS is liable for faults or omissions on its part with- in the scope of the warranty obligations stated in the purchase contract. Claims for damages are excluded, irrespective of the legal reason from which such claims are derived. Only docu- mentation belonging to the actual equipment is valid. Any failure to comply with the safety regula- tions and precautionary measures stated in these operating instructions renders the decla- ration of conformity supplied with the system in accordance with Council Directive (93/42/EEC) concerning medical devices invalid.