Poulan Pro PP8527ESA Manuals

IMPORTANT MANUAL Do Not Throw Away Poulan OWNER'S MANUAL MODEL NUMBER: PP8527ESA SNOW THROWER WARNING: Read the Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. Always Wear Eye Protection During Operation 187887 07.29.03 BY Printed in U.S.A. SAFETY RULES Safe Operation Practices for Snow Throwers IMPORTANT: This machine is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in serious injury or death. Look for this symbol to point out im- portant safety precautions. It means CAUTIONI!! BECOME ALERT!!! YOUR SAFETY IS INVOLVED. WARNING: Always disconnect spark plug wire and place it where it cannot contact plug in order to prevent acci- dental starting when setting up, trans- porting, adjusting or making repairs. WARNING: This snow thrower is for use on sidewalks, driveways and other ground level surfaces. Caution should be exercised while using on sloping surfaces. Do not use snow thrower on surfaces above ground level such as roofs of residences, garages, porches or other such structures or buildings. WARNING: Snow throwers have ex- posed rotating parts, which can cause severe injury from contact, or from ma- terial thrown from the discharge chute. Keep the area of operation clear of all persons, small children and pets at all times including startup. I& CAUTION: Muffler and other engine parts become extremely hot during operation and remain hot after engine has stopped.To avoid severe burns on contact, stay away from these areas. WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemi- cals known to the State of California to cause cancer and birth defects or other reproductive harm. TRAINING Read the operating and service instruction manual carefully. Be thoroughly familiar with the controls and the proper use of the equipment. Know how to stop the unit and disengage the controls quickly. Never allow children to operate the equipment. Never allow adults to operate the equipment without proper instruction. • Keep the area of operation clear of all persons, par- ticulady small children and pets. Exercise caution to avoid slipping or falling especially when operating in reverse. PREPARATION Remove foreign objects. Thoroughly inspect the area where the equipment is to be used and remove all doormats, sleds, boards, wires, rocks & landscaping. Disengage all clutches before starting engine (mo- tor). Do net operate the equipment without wearing ade- quate winter outer garments. Avoid loose, dangling clothing, such as scarves, which can get caught in rotating parts. Wear footwear that will improve footing on slippery surfaces. Handle fuel with care; it is highly flammable. Never smoke while refueling. Use an approved fuel container. Never remove fuel tank cap or add fuel to a running engine (motor) or hot engine (motor). Fill fuel tank outdoors with extreme care. Never fill fuel tank indoors. Replace fuel cap securely and wipe up spilled fuel. Never store fuel or snow thrower with fuel in the tank inside of a building where fumes may reach an open flame or spark. Check fuel supply before each use, allowing space for expansion as the heat of the engine (motor) and/or sun cause fuel to expand. STATIC ELECTRICITY HAZARD - Never fill containers inside a vehicle or on a truck or trailer bed with a plastic liner. Always place containers on the ground, away from your vehicle before filling. When practical, remove gas-powered equipment from the truck or trailer and refuel it on the ground. If this is not possible, then refuel such equipment on a trailer with a portable container, rather than from a gasoline dispenser nozzle. Keep the nozzle in contact with the rim of the fuel tankopening at all times, until refueling is complete. Do not use a nozzle lock-open device. If fuel is spilled on clothing, change clothing im- mediately. For all units with electric starting motors use electric starting extension cords certified CSA/UL. Use only with a receptacle that has been installed in accordance with local inspection authorities. If snow thrower must be operated over gravel surface, use extra caution and be sure skid plates are adjusted to lowest (highest scraper clearance) position. Never attempt to make any adjustments while the engine (motor) is running (except when specifically recommended by manufacturer). Let engine (motor) and snow thrower adjust to outdoor temperatures before starting to clear snow. Always wear safety glasses or eye shields during op- eration or while performing an adjustment or repair to protect eyes from foreign objects that may be thrown from the snow thrower. OPERATION • Do not operate this machine if you are under the influ- ence of alcohol or taking drugs or other medication which can cause drowsiness or affect your ability to operate this machine. • Do not use this machine if you are mentally or physically unable to operate this machine safely. Donotputhandsorfeetnearorunderrotatingparts. Keepclearofthedischargeopeningandfrontauger areaatalltimes. Exerciseextremecautionwhenoperatingonorcross- inggraveldrives,walksorroads.Stayalertforhidden hazardsor traffic. After striking a foreign object, stop the engine (motor), remove wire from the spark plug, thoroughly inspect snow thrower for any damage, and repair the damage before restarting and operating the snow thrower. If the unit should start to vibrate abnormally, stop the engine (motor) and check immediately for the cause. Vibration is generally a warning of trouble. Stop the engine (motor) whenever you leave the oper- ating position, before unclogging the auger/impeller housing or discharge chute and when making any repairs, adjustments, or inspections. When cleaning, repairing, or inspecting, make certain all controls are disengaged and the auger/impeller and all moving parts have stopped. Disconnect the spark plug wire and keep the wire away from the spark plug to prevent accidental starting. Take all possible precautions when leaving the snow thrower unattended. Disengage the auger/impeller, stop engine (motor), and remove key. Do not run the engine (motor) indoors, except when starting the engine (motor) and for transporting the snow thrower in or out of the building. Open the outside doors. WARNING: Exhaust fumes are dan- gerous (containing CARBON MONOX- IDE,an ODORLESS and DEADLY GAS). Do not clear snow across the face of slopes. Exercise extreme caution when changing direction on slopes. Do not attempt to clear steep slopes. Neveroperate the snow throwerwithout properguards, plates or other safety protective devices in place. Never operate the snow thrower near glass enclo- sures, automobiles, window wells, drop-offs, and the like without proper adjustment of the snow discharge angle. Keep children and pets away. Do not overload the machine capacity by attempting to clear snow at too fast a rate. • Never operate the machine at high transport speeds on slippery surfaces. Look behind and use care when backing up. • Never direct discharge at bystanders or allow anyone in front of the unit. Disengage power to the auger/impeller when snow thrower is transported or not in use. • Use only attachments and accessories approved i_y the manufacturer of the snow thrower (such as wheel weights, counterweights, cabs, tire chains, electric start kits, etc.). • Never operate the snow thrower without good visibility or light. Always be sure of your footing and keep a firm hold on the handles. Walk; never run. • Do not overreach. Keep proper footing and balance at all times. • This snow thrower is for use on sidewalks, driveways and other ground level surfaces. • Do not use the snow th rower on surfaces above ground level such as roofs of residences, garages, porches or other such structures or buildings. MAINTENANCE AND STORAGE • Check shear bolts and other bolts at frequent intervals for proper tightness to be sure the equipment is in safe working condition. ° Never store the snow thrower with fuel in the tank inside a building where ignition sources are present such as hot water and space heaters, clothes dryers, and the like. Allow the engine (motor) to cool before storing in any enclosure. Always refer to operator's guide instructions for im- portant details if the snow thrower is to be stored for an extended period. • Maintain or replace safety and instruction labels, as necessary. • Run the snow thrower, with auger engaged, a few minutes after throwing snow to clear the machine and prevent freeze-up of the augeflimpener. CONGRATULATIONS on your purchase of a new snow th rower. It has been designed, engineered and manufactured to give best possible dependability and performance. Should you experience any problem you cannot easily remedy, please contact your nearest authorized service center. We have competent, well-trained technicians and the proper tools to service or repair this unit. Please read and retain this manual. The instructions will enable you to assemble and maintain your snow thrower properly. Always observe the "SAFETY RULES". SERIAL NUMBER: DATE OF PURCHASE: THE MODELAND SERIAL NUMBERSWlLLBE FOUND ON A DECAL ATTACHEDTOTHE REAR OFTHE SNOW THROWER HOUSING. YOU SHOULD RECORD BOTH SERIAL NUMBER AND DATE OF PURCHASE AND KEEP IN A SAFE PLACE FOR FUTURE REFERENCE. PRODUCT SPECIFICATIONS Gasoline Capacity 4.0 Quarts and Type: Unleaded Regular only Oil Type SAE 30 (above 40°F) API-SF-SJ): SAE 5W-30 or 10W-30 (0° to +40°F SAE 0W-30 (below 0°F) Oil Capacity: 26 Ounces Spark Plug: Champion RN4C (Gap: .030") CUSTOMER RESPONSIBILITIES • Read and observe the safety rules. Follow a regular schedule in maintaining, caring for and using your snow thrower. • Follow the instructions under"Maintenance" and "Stor- age" sections of this owner's manual.