Tappan TMV151FSA Manuals

Installation Instructions Over the Range Microwave Oven BEFORE YOU BEGIN Read these instructions completely and carefully. • IMPORTANT - Save these instructions for local inspector's use. • IMPORTANT-observe all governing codes and ordinances. • Note to Installer- Be sure to leave these instructions with the Consumer. • Note to Consumer- Keep these instructions for future reference. • Skill level - Installation of this appliance requires basic mechanical and electrical skills. • Proper installation is the responsibility of the installer. • Product failure due to improper installation is not covered under the Warranty. READ CAREFULLY. KEEP THESE INSTRUCTIONS. irlS[alla[iorl irlstrucuorl_5 CONTENTS General information Important Safety Instructions ..................... 3 Electrical Requirements .............................. 3 Hood Exhaust ........................................... 4, 5 Damage - Shipment/Installation ................. 6 Parts Included ............................................... 6 Tools You Will Need ..................................... 7 Mounting Space ............................................ 7 Step-by-step installation guide Placement of Mounting Plate ................ 8-10 Removing the Mounting Plate ................... 8 Finding the Wall Studs .............................. 8 Determining Wall Plate Location ............... 9 Aligning the Wall Plate ............................ 10 Installation Types ................................. 11-21 A Recirculating ........................................... 12-13 Attach Mounting Plate to Wall ................. 12 Preparation of Top Cabinet ..................... 12 Mount the Microwave Oven ..................... 13 B Outside Top Exhaust .............................. 14-17 Attach Mounting Plate to Wall ................. 14 Preparation of Top Cabinet ..................... 15 Adjust Blower .................................... 15, 16 Check Damper Operation ........................ 16 Mount Microwave Oven ........................... 16 Adjust Exhaust Adaptor ........................... 17 Connecting Ductwork .............................. 17 C Outside Back Exhaust ............................. 18-21 Preparing Rear Wall ................................ 18 Attach Mounting Plate to Wall ........... 18, 19 Preparation of Top Cabinet ..................... 19 Adjust Blower .................................... 19, 20 Mount the Microwave Oven ............... 20, 21 Before You Use Your Microwave .............. 22 irlS[alla[iorl irlstrucuorl_5 IMPORTANT SAFETY INSTRUCTIONS This product requires a three-prong grounded outlet. The installer must perform a ground continuity check on the power outlet box before beginning the installation to insure that the outlet box is properly grounded. If not properly grounded, or if the outlet box does not meet electrical requirements noted (under ELECTRICAL REQUIREMENTS), a qualified electrician should be employed to correct any deficiencies. CAUTION: For personal safety, remove house fuse or open circuit breaker before beginning installation to avoid severe or fatal shock injury. CAUTION: For personal safety, the mounting surface must be capable of supporting the cabinet load, in addition to the added weight of this 59 pound product, plus additional oven loads of up to 50 pounds or a total weight of 109 pounds. CAUTION: For personal safety, this product cannot be installed in cabinet arrangements such as an island ora peninsula. It must be mounted to BOTH a top cabinet AND a wall. NOTE: For easier installation and personal safety, it is recommended that two people install this product. IMPORTANT-PLEASE READ CAREFULLY. FOR PERSONAL SAFETY, THIS APPLIANCE MUST BE PROPERLY GROUNDED TO AVOID SEVERE OR FATAL SHOCK. Insure proper ground exists before use The power cord of this appliance is equipped with a three-prong (grounding) plug which mates with a standard three-prong (grounding) wall receptacle to minimize the possibility of electric shock hazard from this appliance. You should have the wall receptacle and circuit checked by a qualified electrician to make sure the receptacle is properly grounded. Where a standard two-prong wall receptacle is encountered, it is very important to have it replaced with a properly grounded three-prong wall receptacle, installed by a qualified electrician. DO NOT, UNDER ANY CIRCUMSTANCES, CUT, DEFORM OR REMOVE ANY OF THE PRONGS FROM THE POWER CORD. DO NOT USE WITH AN EXTENSION CORD. ELECTRICAL REQUIREMENTS Product rating is 120 volts AC, 60 Hertz, 14.5 amps (13 amps, CANADA) and 1.65 kilowatts (1.5 kilowatts, CANADA). This product must be connected to a supply circuit of the proper voltage and frequency. Wire size must conform to the requirements of the National Electrical Code or the prevailing local code for this kilowatt rating. The power supply cord and plug should be brought to a separate 20 ampere branch circuit single grounded outlet. The outlet box should be located in the cabinet above the microwave oven. The outlet box and supply circuit should be installed by a qualified electrician and conform to the National Electrical Code or the prevailing local code.