Smartech 053420 Instruction Manual

ITEM NO.:053420 ●Massive 22MM aluminum shock body and independent suspension. ●Steel differential gear set and transmission gear. ●Full metal gear 15kg servo. ●High efficiency shaft drive style 4WD system. ●28CC gasoline engine. ●Full ball bearing system. ●High capacity 600CC fuel Tank. ●Front universal shaft included. ● Length..................................750mm ● Width....................................460mm ● Height...................................300mm ● Wheelbase(F/R)...................520mm ● Tread(Front).........................458mm ● Tread(Rear)..........................460mm ● Wheel Diameter..........φ172*80mm ● Gear Rate.................................8.4:1 ● Weight..................................12000g ● Engine.....................................28CC Our company reserves the right to change or modify this manual without notice. WWW.SMARTECHRACING.COM

Throttle Reverse Steering Adjuster Throttle Adjuster Throttle Sensitivity Brake Sensitivity Battery case speed control trigger Steering Reverse Transmitter Steering Rate Adjuster head head d Super Glue (L) (S) The following items are needed for car assembly,please read this instruction manual carefully before operation. s Addition items required for engine staring (Not included in car) carefully before using,The servo must be set in 1 then then

open space. problems or abrupts carbon buid-up pipe were blocked carbon build-up a al of doesn’t didn’t d carbon build-up. something wrong with the Betteries of dry off. Make sure the car is completely assemblied before operate. frequently at following places: It doesn’t means any problems while the car is hard to turning,especially when climbing a slope or driving on bumpy ground. Check all screws and screw caps are tighten. Only use the fuel outdoors! , nearby fire brand or heat producer. been ed . where is also Unproper ed Operating in disorder may cause personal injury and unproperty losing. M or or toavoid Air filter clogged air filter 2 U T T in simultaneously efficiency shadow, Check the batteries. lf model does not operate correctly, stop it and find the cause.

ing the turn on then ing fuel inlet Please make sure using the fuel filter,fuel pipes and related components correctly,to avoid all probability abnormals on the fueling system. 3 e oil rwise, ain Fully extend receiver, .

. on Air filter and sponge should be clean after running around 2 hours. to entend the life of engine and keep high performance. P swiftly after Blocked and air clogged is unavoidable when engine overheat. serious caused spark plug moisture. before drying or replace a spark plug. in at read 4 s P c

φ10×φ4.2×1 φ9.5×φ6×2.4 φ9.7×φ5.7 M4 Sφ8.0×7.6 054410 054410 054410 054410 054408 054408 054410 054410 054410 054410 054410 054410 054410 054409 054410 054410 054408 054408 Fully filled shock absorber oil Front Shock Absorber Rear Shock Absorber ② ① 054406 054407

054077 054078 054078 054078 960026 054077 960026 150004 φ20×φ8.1×0.1 φ16×φ5.1×0.1 φ12×10.1×0.3T φ5×42 M3×6L φ6×55 φ5.0 M5×15 M5×5 M5×5 M4×8 150021 054426 960013 150020 152107 054425 054043 054052 960011 054047 054058 054039 054082 960011 960013 054039 054047 054058 Apply with proper quantities lubricating oil after gear set assembled. Rear Section Assembly (One) 054434 6

Rear Section Assembly (Three) 7

Front Section Assembly (Two) 054433 8

Throttle Servo Assembly Battery Case Assembly

Engine Assembly 10

Roll Cage Assembly 11

Rear Section Assembly 12

Engine Mount Assembly 13

Roll Cage Mount Assembly 14

Roll Cage Tail Assembly 15

x2 x2 054410-Shock Absorber Maintenance x2 x2 x4 x4 x4 x4 x4 x4 x4 x8 x8 x4 x4 x4 054405-Car body 1pcs 054404-Rear upper Pull ing Rod Ball 054406-Front shock absorber unit 054407-Rear shock absorber unit 2set 054401-Wheel unit　 2Sets 054403-Wheel rim unit 2Sets 054402-Tire unit　　　 2Sets 054408-Front/Rear shock absorber 2set 054412-Front shock tower　　 1Pcs 054413-Rear hinge pin brace　　 1Pc 054417-Mid Roll cage-A 1Pc 054418-Mid Roll cage-B 1Set 054419-Rear Roll cage 1Set 054422-Chassis 　 　 1Pc 054421-Tail 　　 1Pc 054423-Side Board 1set spring 1set Head 1sets 1set 2sets body w/ cap 054414-Front upper susp arm　 1Set 054415-Ball end for holder C 2set 054411-Front tower 1Pcs M4×25×2pcs M4×20×2pcs 054416-Front Roll cage 　2Sets M4×20×2pcs M4×20×4pcs M3×6×4pcs M4×6×6pcs 054424-Front lower Susp arm 2Pcs M5×15×2pcs 40140B-Engine 1set 16

054429-Decal 054427-Drive shaft 2Sets 054426-Lower susp hingpin 4Sets 054430-Bumper 1Pc 054425-Rear lower susp arm 2Pcs M5×15×2pcs M4×16×3pcs M3×12×1pc 054432-Body pin 6Pcs 054009-Steering bushing set 1set ISOHM5*5 *2pcs φ5*8pcs 054013-Gear(43T)w/Rubber ring 1 Set 054020-Tie rod & ball end set steering ISOHM5*5 *2pcs 054022-Twin servo horn 　 1Set 054021-Single servo horn 1set M3*10 *1pc 054018-Engine mount-B 　　 1Pc 054019-Engine mount-A 　　 1Pc 054017-Flywheel fixed holder 1set 054320-Brake disc set 1Set 054010-Steering post 　　 　2Pcs 054011-Servo saver post w/spring 1set 054012-Steering bellcrank set　　 1set 054024-Center diff.mount　　　 2Pcs 054025-Brake drive stub 2Pcs 054008-Steering draglink　 1Pc 054428-Tie rod & ball end steering 054014-Gear(37T)w/Rubber ring 1 Set 1set 1Sets 17

054028-Brake rod set　 3Sets ISOHM3*3 *9pcs 054027-Brake shaft set 　 1set ISOHM4*4 *2pcs 054026-Center diff.bevel gear(57T) 1set M4*8L *4pcs 054030-Throttle steering holder　 1Set M4*32 *4pcs 054033-Upper ball head for shodk 054031-Diff.brace　　 1Pc 054043-Driver cup　 　2Pcs ISOHM5*5 *4pcs 054034-Upper susp Hing pin w/ e-clip 054038-Lower susp shaft　 　　1Pc M4*20 *2pcs 054039-Diff.gear box　 1set 054047-Diff.drive stub　　 　2Pcs M4*16 *2pcs 054041-Rear hinge pin brace 1Set M4*16 *2pcs 054042-M8*40 Upper front Turn Buckle 054045-Center diff.erential bevel 054035-Bulkhead screw pin 1Pc 054051-Steering arm 　　 1Set 054052-Pinion bevel gear(16T)　2Pcs 054053-C hub carrier　 1Set 054054-Rear susp mount 1Set 054058-Diff.ring(44T)　　 2Pcs TPF4*8L 4pcs 054044-Front arm mount　 　 1Pc 054040-Front Hinge pin brace 1Set 301030-Receiver switch 1pc absorber 4sets 2sets 2pcs 1set gear(16T) 18

054060-Dogbone center front　　2Set 054061-Dogbone center rear　　2Set M4*12 2pcs 054063-Front center brace　　 1set 054064-Fuel pipe set 1Set 054065-Fuel tank unit　　 1Set M4*12 4pcs M4*10 4pcs 054067-Servo mount　 1Set 054066-Battery 　 1Pc 054068-Battery case　　 　1Set 150004-Diff.erential gear unit 1Set 054077-Diff.erential gear set 1Set 054078-Diff.erential gear box 1Set 054084-Exhaust pipe　 1Set 054070-Gear cap 　 1Set 150024-Aluminum washer 4pcs 150034-Flywheel 1set 150020-Hub rear 1set 150021-Wheel rim joint 2set ISOHM5*5 x2pcs 150052-Oil tube fixing clip 1set x4 x2 x3 x4 301320-15Kg servo 1pc 150059-Ball head holder B 4pcs 150063-Body pln 6pcs 083071-Antenna tube w/cap 1Set 152107-Diff.drive stub 2pcs 19

920006-Locknut M4 6pcs 920009-Locknut M6 6pcs 930005-E-clip Φ4 6pcs 920008-Locknut M5 6pcs 053420(SMT)PARTS LIST(5) 950007-Washer 17*6.1*1T 6pcs 950006-Washer 12*8.1*1T 6pcs 960011-Bearing 10*19*7 6pcs 960012-Bearing 10*22*6 6pcs 960013-Bearing 8*22*7 6pcs 960026-Bearing 12*24*6 6pcs 960008-Bearing 6*10*3 6pcs 054080-Washer 16*12.2*0.3T 6pcs 054081-Washer 16*12.2*0.6T 6pcs 054082-Washer 12*10.1*0.3T 6pcs 054083-Washer 10*5.1*1.0T 6pcs 930003-E-clip Φ5 6pcs 910074-Flat head screw M5*30 6pcs 910067-Flat head screw M4*16 6pcs 910114-Cap screw M5*28 6pcs 910115-Cap screw M5*43 6pcs 910116-Cap screw M6*41 6pcs 910166-Button head screw TT4*12 910059-Flathead screw M3*15 6pcs 6pcs 20

6pcs 910111-Cap screw M4*20 6pcs 910204-Round head screwPT4*20 6pcs 053420(SMT)PARTS LIST(6) 910208-Flat head screw M5*20 6pcs 910206-Round head screw M4*21 6pcs 910209-Flat head screw M5*16 6pcs 910036-Fiat head screw ISO3*25 6pcs 910205-Button head screw PT5*28 6pcs 054433-Front wheel Axec spacer 8*11*6T 2pcs 054434-Rear wheec Axel spacer 8*11*11.2T 2pcs 21

(5)/950007 (5)/920009 (5)/950007 (5)/920009 (6)/054434 (6)/054433 (2)/054320 Note: the marks (1),(2),(3),(4),(5),(6)in this chart correspond with the parts list. 22

(5)/950007 (5)/920009 (5)/950007 (5)/920009 (6)/054434 (6)/054433 (2)/054320 Note: the marks (1),(2),(3),(4),(5),(6)in this chart correspond with the parts list. 22