Alva CCR110 Manual 

• NOTE: This appliance needs to be burnt for 10 minutes before first use, to eliminate material odour. • Please read these instructions carefully before using your butane oven. • The operator must understand all safety requirements as detailed in this manual before using the unit. • The operator is responsible for the safety of all third parties while the butane oven is in use. • The manufacturer’s warranty may be voided by incorrect use of this product. • If you have any queries regarding these instructions, contact your local dealer for clarification before you use your oven. • Always remove unit from all packaging materials prior to use. • The unit must be thoroughly checked before use. Check that the seals between the appliance and the gas cartridge are in place and in good condition before connecting the gas cartridge. DO NOT use this appliance if it has damaged or worn seals. Tweezers can be used to pull the damaged/ worn seal out and replace it with a new seal or call 086 100 ALVA (2582) • Failure to follow the manuals instructions could result in damage or serious injury. • The unit must only be used on a flat horizontal, stable, non- slip and non-combustible surface.. • Ensure that all butane fittings are correctly and firmly fitted. Do this check every time before use. • DO NOT store flammable materials near the oven. • DO NOT place or use aerosol sprays near the oven. • Use only the gas type specified on the nameplate of the unit. • DO NOT leave the stove unattended when it is alight. • Onlookers should keep a safe distance away from the butane oven when it is in use. • Keep children and animals well away while the butane oven is in use. • Parts of the butane oven will get extremely hot and could cause serious burns - test every surface before touching it. • Be very careful when operating the cooker. The operator should pay constant attention to the food being cooked and should remain at the appliance at all times when it is alight. • Ensure that the butane oven is turned OFF after use and while the butane oven is unattended. • When turning off the butane oven, turn the control knob to the ‘O’ position. • Neither the Manufacturer nor their Agents can accept any liability for the unsuitability of, or any damage to, any food cooked on this appliance. Please read the instructions carefully before use. Retain this manual for future reference

• DO NOT use in a wind, breeze or draught. • Avoid boil overs and spills. Do not overfill your cooking vessels. • DO NOT use pots or dish with a diameter greater than 250mm. • DO NOT use or place the stove near other heat sources such as heaters, electrical appliances or flammable materials. • DO NOT touch the burner head, drip tray, pot holder etc. immediately after or during use. • Do not smoke while operating the appliance. • Do not carry or move the cooker while in use. • Keep this appliance away from combustible materials during operation. Keep minimum clearances of: Rear 250mm, Sides 250mm, Top 1200mm. • DO NOT use the oven if you suspect that the unit is faulty. • DO NOT use this appliance if it is leaking, damaged or does not operate properly. • Ensure the butane cartridge is removed from the oven before storage. • Carbon monoxide hazard: This appliance can produce carbon monoxide which has no odour. Using it in an enclosed space (e.g. caravan, tent, car, mobile home) may result in death. • This appliance is to be used for cooking only. DO NOT use the appliance as a heater, drying apparatus or to start a wood fire. • DO NOT use multiple stoves to heat a single vessel. • DO NOT heat multiple vessels on this single unit. • DO NOT attempt any repairs yourself. This appliance must only be serviced by an authorised professional. • Any modification to the butane oven may cause injury or property damage. • Any modification to the oven will invalidate the guarantee on this appliance. • Butane canister not included. • The burner supplied with your cooker is considered to be a consumable spare. Frequency of use, environmental factors and failing to follow the cleaning and care instructions in this manual may cause your cooker burner to corrode. This is not considered a manufacturing fault, but rather normal wear and tear and is not covered under our warranty. Should you need to replace your burners please contact our customer care department. Please read the instructions carefully before use. Retain this manual for future reference

PRECAUTIONS ABNORMAL OPERATION MAINTENANCE BURN BACK (FIRE IN BURNER TUBE OR CHAMBER) TROUBLE SHOOTING GUIDE SPECIFICATIONS AFTER SALES SERVICE KEY Notes marked with the following; Contain important information Notes marked with the following; Contain cautions and warnings.

purchase of this gas cooker. Please read these instructions carefully before use and keep them in a safe place for future reference. 2 PART NAMES 1. Oven Drip Tray 4. Flame Timer 7. Control Knob 2. Oven Shelf 5. Flame Safety Button 8. Cartridge Lever 3. Thermometer 6. Cartridge Cover 9. Burner OPERATING INSTRUCTIONS 1. Turn the control knob to the OFF position. Make sure that the cartridge lever is in the UNLOCK position. If the gas knob is in the ON position, the cartridge cannot be put into position. 2. Open the cartridge cover and insert the gas cartridge. Make sure that the cartridge slot fits into the cartridge lever guide on the valve. (Caution: Use only approved butane gas cartridge EN417) 3. When you are ready to the use the oven, push the cartridge lever down to the FUEL-LOCK position. If a hissing sound or gas smell occurs, check that the cartridge is fitted correctly. Repeat step 2 to stop the gas leak. If lever is hard to push down, do not force it. Check that the cartridge is fitted correctly and the control is in the OFF position.

2. Set the oven timer to 10 minutes. 3. Press and hold the flame safety button. 4. Turn the control knob towards the IGNITION position until a click is heard from the piezo ignitor. 5. If ignition fails, turn the control knob back to the OFF position and repeat step 4. 6. Continue to hold the flame safety button for 15 seconds after the burner is alight. If you release the flame safety button too early, the safety mechanism will shut off the flame. HEAT CONTROL: 1. The control knob can be positioned on ‘Maximum’, Minimum, etc. Adjust it to the suitable position to control the temperature in the oven. 1. When you have finished cooking, turn the control knob to the OFF position. Confirm that the flame is completely extinguished. 2. Raise the cartridge lever to the UNLOCK position, and take out the gas cartridge. 3. The oven timer will automatically shut off the burner when it returns to the ZERO/OFF position. EXTINGUISHING 2. When turning the control knob from ‘Maximum’ to ‘Minimum’, turn slowly towards ‘Minimum’. 3. Set the oven timer to the desired cooking time.

IF YOU SMELL GAS OR HISSING SOUND • Turn the ignition knob on the stove to ‘O’ , to stop the gas flow and turn the unit off. • Ventilate the area. • Check for leaks (see LEAK TEST) • If odour or sound persists, release the cartridge lock lever to the upward posi- tion and remove and isolate the gas cartridge and contact your dealer or local gas supplier immediately. WARNING • Never put butane cartridge, aerosol cartridges or any type of fuel container inside the oven compartment. • Never put items such as briquettes or heat beads in the oven compartment. • Do not use for any purpose other thank cooking food. • During use parts may become very hot. Keep young children away. • Switch cartridge lever to UNLOCK position when appliance is not in use. • Do not store cartridge in cartridge compartment during transportation or storage. • Fit the nozzle cap back onto the cartridge to protect the nozzle and accidental gas leakage if nozzle is bumped or depressed. • Avoid boil over and spillage. • When hot only handle the appliance by the control surface intended to be touched. • Allow to cool before moving or handling. • Do not use as a space heater. • Remove all packaging before use. Do not operate oven in carry bag. (Where included). • CAUTION: Never obstruct the air openings or vents on this appliance. PRESSURE SENSITIVE SAFETY DEVICE If the oven is used in a hot area such as outdoors in direct sun- light or incorrectly (not in accordance with these instructions), the internal pressure of the cartridge will increase. If the pressure reaches a dangerous level the built-in mechanical safety device will activate stopping the flow of gas and extinguishing the flame. If the built-in safety device activates, determine and correct the cause before reusing the oven until the problem is resolved. The oven features a second safety device to shut off the flow of gas and extinguish the flame. If the second safety device is activated, the oven cannot be relit until the oven has been cooled.

EN417. IT MAY BE HAZARDOUS TO ATTEMPT TO FIT OTHER TYPES OF GAS CARTRIDGES. 2. The cartridge should be placed away from flammable products or direct sunlight. Never keep cartridge in places where the temperature is over 50ºC. 3. Do not subject the cartridge to impact or rough handling. 4. Cartridges must be stored outdoors in a well ventilated location out of reach of children. 5. Do not puncture or incinerate empty cartridge. 6. Avoid carrying cartridge in the boot of a car or any unventilated enclosure. 7. Gas cartridge shall be changed in a well ventilated location, preferably outside, away from people and any source of ignition such as naked flames, electric heaters/equipment. 8. To check if gas cartridge contains gas, disconnect from the oven, then hold upright and shake from side to side. If you can feel or hear liquid moving, it contains gas. OVEN: 1. Check the seals between the appliance and the gas cartridge are in place and in good condition before connecting the gas cartridge. 2. Do not use this appliance if it has a damaged or worn seal. 3. Do not use the appliance if it is leaking, damaged or does not operate properly. 4. If there is a leak on your appliance (smell of gas) and you cannot stop the gas flow, remove the appliance to a well ventilated location away from any ignition source. Only check for leaks outdoors using soapy water solution. Do not try to detect leaks using a flame. 5. This appliance must only be serviced by an authorised person. 6. Do not modify this appliance. USE: 1. Do not use for any purpose other than cooking. Incorrect use may result in overheating, incomplete combustion and/or a risk of fire or explosion. 2. In the event of a gas leak (smell of gas) immediately turn the control to the off position and move the cartridge lever to the unlock position to isolate the gas supply. 3. Do not move the appliance during operation. 4. The maximum cooking tray size is 28.5cm x 28.5cm

connections after each canister installation. NEVER check for leaks with a match or open flame Any Butane cartridge not connected for use must not be stored in the vicinity of this or any other appliance. 6 PLACEMENT: 1. Do not use the oven in very windy conditions. 2. Do not place or use this appliance on any hot surface. 3. Do not use the oven under overhanging shelves etc. Refer to previous page. 4. Do not use close to combustible materials such as curtains. No combustible materials should be within 40cm from any side of or 120cm above the oven. 5. Use oven in the shade or in a cool place. Avoid using in direct sunlight. 6. Only operate this appliance on a flat horizontal surface to ensure the aeration opening below the oven is clear and unobstructed. 7. ONLY USE IN WELL VENTILATED AREAS: CARBON MONOXIDE HAZARD - USING THE APPLIANCE IN AN ENCLOSED SPACE MAY CAUSE DEATH. DO NOT USE IN CARAVANS, TENTS, MARINE CRAFTS, CARS, MOBILE HOMES OR SIMILAR LOCATIONS. ABNORMAL OPERATION ABNORMAL OPERATION CAN BE IDENTIFIED BY: • Frequently activation of pressure safety device. • Jamming of cartridge lock lever. • Irregular burner flame which is yellow or unstable. • Black sooting of cooking utensils. • Refer to the trouble shooting section of this manual for possible solutions. • If the oven does not operate properly DO NOT use the appliance.

gasoline or other flammable vapours and liquids in the vicinity of this or any other appliance DO NOT use pots that are larger or over hang the body of this cooker. 7 MAINTENANCE PRECAUTIONS: 1. Make sure that the gas cartridge is released before cleaning. 2. Never remove safety device or gas components. CLEANING: 1. Body: Wipe off with a clean cloth. When necessary, use cleanser and then finish with a dry cloth. 2. Drip tray and oven shelf: After washing, wipe with a dry cloth. 3. Burner: Clean the burner, burner ports, spark electrode and brass themocouple with a hard brush. TROUBLE SHOOTING BURN BACK (FIRE IN THE BURNER TUBE OR CHAMBER) In the event of a burn-back, where the flame burns back to the jet, immediately turn the gas supply off at the control valve on the panel. After ensuring the flame is extinguished, wait for 1 minute and re-light the appliance in the normal manner. Should the appliance again burn back, close the control valve and call a service technician. Do not use the appliance again until the service technician has declared that it is safe to do so.

Gas Butane Gas Injector size 0.42mm Ignition Piezo Operating Pressure Butane Canister Vapour Pressure Heat Output 1.1kW Gas consumption at Max 100gr/hr Any modification to the stove may cause injury or property damage. Any modification to the stove will invalidate the guarantee on this appliance. AFTER SALES SERVICE MANUFACTURED FOR AND DISTRIBUTED BY Alva Marketing (Pty) Ltd P.O. Box 30014 Tokai, 7966 Tel: 021 442 1540 E-mail: [email protected] www.alva.co.za @StingrayGroupSA www.facebook.com/AlvaGas TOLL FREE NUMBER 086 100 ALVA (2582) Should you experience problems with this butane stove, carry out the necessary checks as per the Trouble Shooting Guide . If you are still unable to correct the problem with the information in this guide, then you need to contact your nearest dealer or manufacturer. 8