Rotel RC-1090 Technical Manual

RC-1090 Table of Contents Specification Specification...................................... 1 Parts List........................................... 2~4 Case Outlines.................................... 4~5 Safety Caution................................... 5 PCB Assembly .................................. 6~8 Schematic Diagram .......................... 9~12 Total Harmonic Distortion <0.004 % 　　　 (20 Hz - 20 kHz 8 ohms) Intermodulation Distortion <0.004 % at 1V output 　　　 (60 Hz : 7 kHz 4 : 1) Input Sensitivity / Impedance Phono - MC 0.25 mV / 100 ohms Phono - MM 2.5 mV / 47 kohms Line Level 150 mV / 18 kohms Phono Overload (MC/MM) 16 mV / 160 mV Output Level / Impedance 1 V / 100 ohms Frequency Response Phono Input 20 Hz - 20 kHz, ± 0.2 dB Iine Level Input 4 Hz - 100 kHz, ± 0.5 dB Signal to Noise Ratio (IHF "A" weighted) Phono - MC / MM 70 dB / 75 dB Line Level 100 dB Power Requirements USA Version 115 volts, 60 Hz European Version 230 volts, 50 Hz Power Consumption 13 Watts Dimensions (W x H x D) 430 x 125 x 345 mm 1615/16 x 415/16 x 1319/32" Weight (net) 7.8 kg/17.2 lb. SHINSEN-BLD. 4F 10-10 SHINSEN-CHO, SHIBUYA-KU, TOKYO 150-0045, JAPAN Serial. NO. Beginning Y-340A-01015C/S-S

044 TFKP2-2A101H 044 FSC160V331H 044 FSC160V101H 044 TFKP2-2A102F 041 50BGF10M 044 PP160V6800PF 041 25BGF100M 041 ECEA1EF471 041 50BGF10M 043 TC50V473 041 UTES1E101-FB 041 UTES1H100-FB 041 25BGF47M 044 TFKP2-2A101H 041 50BGF010M 041 25BGF47M 041 35BGF100M 041 35BGF470M 041 UTES1H4R7-FB 043 TC50V103 041 UTES1E470-FB 041 ALN20S1078DD ※043 TC500V103 041 UTES1V101-FB 043 TC500V103 034 T1N4148-86 034 TRD18JST1 034 T1N4148-86 034 T1N4148-86 034 MA27W-A 034 E-562 034 T1N4148-86 034 T1N4148-86 034 T1N4148-86 034 BR84 ※ 034 T1N4148-86 036 5ST2.5 ※ 031 TL071CP 031 NE5534AN-S 031 TC9163AN 031 LC4966 031 TC74HC595AP 031 NJM7815FA 031 NJM7915FA 066 4TR-2672#3 032 D786-RS 033 TC2362-FG 033 D600-EF 033 B631-EF 032 TA1345 032 TC3399 032 TA1345 032 TC3399 033 TC2362-FG 033 TA1016-FG CAPACITOR FILM 100V100PF CAPACITOR STYROL 160V330PF CAPACITOR STYROL 160V100PF CAPACITOR FILM 100V1000PF CAPACITOR ELEC.50V10UF CAPACITOR FILM 160V6800PF CAPACITOR ELEC.25V100UF CAPACITOR ELEC.25V470UF CAPACITOR ELEC.50V10UF CAPACITOR CERA.50V0.047UF CAPACITOR ELEC.25V100UF CAPACITOR ELEC.50V10UF CAPACITOR ELEC.25V47UF CAPACITOR FILM 100V100PF CAPACITOR ELEC.50V1UF CAPACITOR EELC.25V47UF CAPACITOR ELEC.35V100UF CAPACITOR ELEC.35V470UF CAPACITOR ELEC.50V4.7UF CAPACITOR CERA.50V0.01UF CAPACITOR ELEC.25V47UF CAPACITOR ELEC.63V4700UF CAPACITOR CERA.500V0.01UF CAPACITOR ELEC.35V100UF CAPACITOR CERA.500V0.01UF DIODE ZENER DIODE DIODE DIODE VARISTOR DIODE CURRENT REGULATIVE DIODE DIODE DIODE DIODE BRIDGED DIODE DIODE MINI FUSE 250VT2.5A IC(OPE AMP) IC(SELECTED OPE AMP) IC(SWITCH ALLEY) IC(LOGIC SWITCH) IC(8BIT SHIFT REGISTER/LATCH) IC(REGULATOR +15VDC) IC(REGULATOR -15VDC) 4P PINJACK TRANSISTOR(2SD786-RS) TRANSISTOR(2SC2362K-FG) TRANSISTOR(2SD600K-EF) TRANSISTOR(2SB631K-EF) TRANSISTOR(2SA1345) TRANSISTOR(2SC3399) TRANSISTOR(2SA1345) TRANSISTOR(2SC3399) TRANSISTOR(2SC2362K-FG) TRANSISTOR(2SA1016K-FG) Q513-516 Q517.518 Q519.520 Q521.522 Q523.524 Q525.526 Q527.528 R401.402 R403.404 R405.406 R407.408 R409.410 R411-414 R415.416 R417.418 R419.420 R421.422 R423.424 R425.426 R427.428 R429.430 R431.432 R433.434 R435.436 R451-464 R465.466 R467-470 R471.472 R474 R476 R477 R501.502 R503.504 R505-512 R513-516 R517.518 R519-522 R523.524 R525.526 R527.528 R529-532 R533.534 R535.536 R559.560 R611 R717 R903 R905.906 RY451-458 RY601.602 RY901 RY902 S401 VR501 033 TC2362-FG 033 C2911-ST 033 A1209-ST 033 B631-EF 033 D600-EF 032 TC536-FG 032 TA608-FG 054 EE10-473 054 EE10-101 054 EE10-100 054 TMFR4560R 054 TMFR4047R 054 TMFR405K6 054 TMF4700 054 TMFR4022K 054 TMFR4270R 054 TMFR402K7 054 TMFR4075K 054 TMFR404K7 054 TMFR4470K 054 TMFR4100R 054 TMFR4100K 054 TMFR4047K 054 TMFR401K5 054 MF16-1001-A 054 TMFR4001K 054 MF16-1001-A 053 CR14-470J-A 053 CR14-104J-A 053 CR14-474J-A 053 CR14-561J-A 054 EE10-101 054 EE10-393 054 TMFR401K2 054 TMFR4270R 054 TMFR4022K 054 TMFR4470R 054 TMF1/4-2200F 054 TMF1/4-3301F 054 TMFR4018K 054 TMFR4010R 054 TMFR4100R 054 TMFR4047K 054 TMFR4560R 054 1WS330JF 053 CR16-104J-A 054 1WS120JF 054 2WS100JF 063 V23106-24 063 V23106-24 063 DH2U-24 ※ 063 DG1U-24 ※ 061 4TR-3301 051 C-4170A33 017 C-4401A01 TRANSISTOR(2SC2362K-FG) TRANSISTOR(2SC2911-ST) TRANSISTOR(2SA1209-ST) TRANSISTOR(2SB631K-EF) TRANSISTOR(2SD600K-EF) TRANSISTOR(2SC536K-FG) TRANSISTOR(2SA608K-FG) RESISTOR METAL 47K RESISTOR METAL 100R RESISTOR METAL 10R RESISTOR METAL 1% 560R RESISTOR METAL 1% 47R RESISTOR METAL 1% 5.6K RESISTOR METAL 470R RESISTOR METAL 1% 22K RESISTOR METAL 1% 270R RESISTOR METAL 1% 2.7K RESISTOR METAL 1% 75K RESISTOR METAL 1% 4.7K RESISTOR METAL 1% 470K RESISTOR METAL 1% 100R RESISTOR METAL 1% 100K RESISTOR METAL 1% 47K RESISTOR METAL 1% 1.5K RESISTOR METAL 1K RESISTOR METAL 1% 1K RESISTOR METAL 1K RESISTOR CARBON 47R RESISTOR CARBON 100K RESISTOR CARBON 470K RESISTOR CARBON 560R RESISTOR METAL 100R RESISTOR METAL 39K RESISTOR METAL 1% 1.2K RESISTOR METAL 1% 270R RESISTOR METAL 1% 22K RESISTOR METAL 1% 470R RESISTOR MRS25 220R RESISTOR MRS25 3.3K RESISTOR METAL 1% 18K RESISTOR METAL 1% 10R RESISTOR METAL 1% 100R RESISTOR METAL 1% 47K RESISTOR METAL 1% 560R RESISTOR METAL 1W 330R RESISTOR CARBON 100K RESISTOR METAL 1W 120R RESISTOR METAL 2W 100R RELAY(FUNCTION) RELAY(MUTE) RELAY(POWER) RELAY(AC OUTLET) PUSH SWITCH(MC/MM) VARIABLE RESISTOR(VOLUME) SUB HEAT SINKER SYMBOL PARTS NO. DESCRIPTION SYMBOL PARTS NO. DESCRIPTION

X-1299-02 PCB ASSEMBLY 044 S50V47PJ 042 TP50V103J 041 UTES1E101-FB 043 TC50V103 043 TC500V103 041 UTES1H010-FB 041 UTES1V101-FB 041 UTES1A101-FB 041 UTES1H470-FB 043 TC500V103 041 UTES1V102 041 UTES1E101-FB 034 TRD5.6JST1 034 T1N4003-TB ※ 034 TRD4.7JST1 034 T1N4148-86 034 TRD30JST1 034 TRD9.1JST1 034 TRD12JST1 034 T1N4003-TB ※ 065 C-3399#3 031 NJM4556AD 031 LB1641 031 NJM7805FA 033 TC3708-ST 033 TA1016-FG 032 TC536-FG 032 TD863-EF 054 TMFR4100K 054 TMFR4330K 054 TMFR4033K 054 TMFR4150R 054 TMFR4047K 053 CR14-821J-A 053 CR16-100J-A 053 CR14-103J-A 054 ERQ14AJ2R2P ※ 054 1WS180JF 054 1WS330JF 053 CR14-153J-A 053 CR14-472J-A 053 CR14-682J-A 053 CR14-473J-A 053 CR14-223J-A 053 CR14-104J-A 054 1WS68JF 053 CR14-272J-A 054 1WS180JF 054 ERQ14AJ2R2P ※ 053 CR16-2R2J-A INSULATION SHEET FUSE CLIP AC OUTLET for STD CAPACITOR STYROL 50V47PF CAPACITOR MYLAR 50V0.01UF CAPACITOR ELEC.25V100UF CAPACITOR CERA.50V0.01UF CAPACITOR CERA.500V0.01UF CAPACITOR ELEC.50V1UF CAPACITOR ELEC.35V100UF CAPACITOR ELEC.10V100UF CAPACITOR ELEC.50V47UF CAPACITOR CERA.500V0.01UF CAPACITOR ELEC.35V1000UF CAPACITOR ELEC.25V100UF ZENER DIODE DIODE ZENER DIODE DIODE ZENER DIODE ZENER DIODE ZENER DIODE DIODE PHONE JACK IC(DUAL OPE) IC(MOTOR DRIVE) IC(REGULATOR +5VDC) TRANSISTOR(2SC3708-ST) TRANSISTOR(2SA1016K-FG) TRANSISTOR(2SC536K-FG) TRANSISTOR(2SD863-EF) RESISTOR METAL 1% 100K RESISTOR METAL 1% 330K RESISTOR METAL 1% 33K RESISTOR METAL 1% 150R RESISTOR METAL 1% 47K RESISTOR CARBON 820R RESISTOR CARBON 10R RESISTOR CARBON 10K FUSIBLE RESISTOR 2.2R RESISTOR METAL 1W 180R RESISTOR METAL 1W 330R RESISTOR CARBON 15K RESISTOR CARBON 4.7K RESISTOR CARBON 6.8K RESISTOR CARBON 47K RESISTOR CARBON 22K RESISTOR CARBON 100K RESISTOR METAL 1W 68R RESISTOR CARBON 2.7K RESISTOR METAL 1W 180R FUSIBLE RESISTOR 2.2R RESISTOR CARBON 2.2R R930 S901 C517.518 C519.920 C918.919 D908 D912 DJ1.DJ2 IC501 Q529.530 Q905 Q906 R537-540 R541-544 R545.546 R557 R558 R920.921 RY501 S501 C521-524 DJ3.DJ4 IC502.503 R547-550 R551-554 R555.556 S502 C701.702 C706 C708 C709-712 C718 C719 C721 C722 D701-706 D708 D714 FL701 IC701 Q701 R702 R703-707 R709-713 R714 R715 R718 R719 R720 053 CR16-103J-A 061 4TR-2947 X-1299-03 PCB ASSEMBLY 041 25BGF47M 041 25BGF100M 041 25BGF470M 034 TRD16JST1 034 TRD16JST1 066 C-4516A01 031 AD712JN 032 TC536-FG 033 TA1450-ST 033 TC3708-ST 054 TMFR4010K 054 TMFR4100R 054 TMFR4047K 053 CR14-104J-A 053 CR14-331J-A 054 TMFR401K5 063 V23106-24 064 4TR-2341 X-1299-04 PCB ASSEMBLY 041 25BGF100M 066 C-4575A01 031 AD711JN 054 TMFR4022K 054 TMFR4010K 054 TMFR4001K 064 4TR-2341 X-1300-01 PCB ASSEMBLY 043 TC50V473 044 50MSAN104J 041 FYD0H224Z 043 TC50V101 041 UTES1H100-FB 041 UTES1HR22-FB 043 TC50V101 041 UTES1A101-FB 034 T1N4148-86 034 T1N4148-86 034 T1N4148-86 035 SVR-12MM18 031 CXP82832-311Q 032 TC536-FG 053 CR16-101J-A 053 CR16-102J-A 053 CR16-473J-A 053 CR16-472J-A 053 CR16-104J-A 053 CR16-102J-A 054 SE4473J 053 CR16-473J-A RESISTOR CARBON 10K PUSH SWITCH(STANDBY) CAPACITOR ELEC.25V47UF CAPACITOR ELEC.25V100UF CAPACITOR ELEC.25V470UF ZENER DIODE ZENER DIODE 3P CANNON SOCKET(MALE) IC(DUAL OPE) TRANSISTOR(2SC536K-FG) TRANSISTOR(2SA1450-ST) TRANSISTOR(2SC3708-ST) RESISTOR METAL 1% 10K RESISTOR METAL 1% 100R RESISTOR METAL 1% 47K RESISTOR CARBON 100K RESISTOR CARBON 330R RESISTOR METAL 1% 1.5K RELAY(BALANCED) SLIDE SWITCH(BALANCED) CAPACITOR ELEC.25V100M 3P CANNON JACK(FEMALE) IC(OPE AMP) RESISTOR METAL 1% 22K RESISTOR METAL 1% 10K RESISTOR METAL 1% 1K SLIDE SWITCH(BALANCED) CAPACITOR CERA.50V0.047UF CAPACITOR FILM 50V0.1UF CAPACITOR 5.5V0.22F CAPACITOR CERA.50V100PF CAPACITOR ELEC.50V10UF CAPACITOR ELEC.50V0.22UF CAPACIOTR CERA.50V100PF CAPACITOR ELEC.10V100UF DIODE DIODE DIODE FL TUBE IC(FL DRIVE) TRANSISTOR(2SC536K-FG) RESISTOR CARBON 100R RESISTOR CARBON 1K RESISTOR CARBON 47K RESISTOR CARBON 4.7K RESISTOR CARBON 100K RESISTOR CARBON 1K THICK FILM RS NETWORK 47K RESISTOR CARBON 47K SYMBOL PARTS NO. DESCRIPTION SYMBOL PARTS NO. DESCRIPTION

041 UTES1H010-FB 034 TRD12JST1 034 T1N4148-86 065 YKB21-5103A 031 HIN232CP 031 PC817B 032 TC536-FG 053 CR16-332J-A 053 CR16-103J-A 053 CR16-102J-A 053 CR16-100J-A 053 CR16-101J-A 066 SY010-8P/K X-1300-03 PCB ASSEMBLY 041 UTES1E470-FB 031 SBX3010-52B 053 CR16-101J-A THICK FILM RS NETWORK 100K THICK FILM RS NETWORK 100K THICK FILM RS NETWORK 100K TACT SWITCH TACT SWITCH CERAMIC RESONATOR CAPACITOR ELEC.50V1UF ZENER DIODE DIODE MINI JACK IC(TRANSMITTER RECEIVER) IC(PHOTO COUPLER) TRANSISTOR(2SC536K-FG) RESISTOR CARBON 3.3K RESISTOR CARBON 10K RESISTOR CARBON 1K RESISTOR CARBON 10R RESISTOR CARBON 100R COMPUTER I/O TERMINAL CAPACITOR ELEC.25V47UF IC(REMOTE EYE) RESISTOR CARBON 100R OTHERS 011 FP-533 011 TH3-01A00 012 C-4711A01 012 RV4-09A00 014 C-4723A02 014 TH3-10A00 015 RP-384B 019 PK4-07A00T 022 T-1077T01 ※ 034 SEL1124R 069 C-4629A01 ※ 072 C-4621A01 ※ 072 C-4622A01 ※ 072 C-4623A01 ※ 072 C-4624A01 ※ 081 TH3-11A00 081 Z-204 092 RR-969 SUB PANEL ASSY H/S PANEL KNOB ASSY 43F PUSH KNOB 14F UPPER COVER BOTTOM BOARD REAR CHASSIS METAL FOOT ASSY 60F POWER TRANSFORMER LED 1X5 AC INLET AC CORD SET for STD AC CORD SET for AUSTRALIA AC CORD SET for UK AC CORD SET for CEE INSIDE CARTON STYROL MOULDING REMOTE UNIT SYMBOL PARTS NO. DESCRIPTION SYMBOL PARTS NO. DESCRIPTION NOTE ON SAFETY : Symbol ※ Fire or electrical shock hazard. Only original parts should be used to replaced any part marked with symbol ※ . Any other component substitution (other than original type), may increase risk of fire or electrical shock hazard. 2SA608K 2SA1016K 2SA1450 2SC536K 2SC2362K 2SC3708 2SD863 2SA1345 2SC3399 2SD786 2SB631K 2SA1209 2SD600K 2SC2911 LB1641 NJM78XXFA NJM79XXFA PC817B

1. Keep in mind the safety warnings The safety instructions are shown as the labels or printings on the exterior, the inside chassis or the parts, etc. Refer to the instructions when proceeding with inspection or repair. 2. Use only the specified parts for replacement The selected parts are used at critical area to reduce fire hazard or electrical shock. So when replacing these parts where designaged with marks or ※ marks on the schematic diagram or the parts list, ensure to use only the same parts. 3. Ensure to dress back the AC (Mains) cord to the original position If for some reason, the AC cord is moved or partially disassembled, ensure to re- route or assemble back to the original position. The AC cord area is protected and secured by tubing and insulation materials for the sake of safety, so that no loose wire will touch and cause fire hazard and electrical shock. 4. Check for safety aspects after inspection or repair Ensure all parts, such as screws or wires, removed during inspection or repair are secured back to the original positions, and check visually for any anomaly. Also check for any electrical leakage or resistance to maintain the safety. AD711JN AD712JN NE5534AN NJM4556AD TL071CP LC4966 HIN232CP TC74HC595AP TC9163AN CXP82832