EdgeStar DEP501EW Ower's Manual

on other great EdgeStar products on the web, go to http://www.edgestar.com

dehumidifier and/or to the user. This dehumidifier is designed for domestic indoor use only. Do not use the unit for industrial or commercial use. Any other use may invalidate the warranty. Please review the ratings label located on the rear panel of the unit for electrical and other technical data related to this unit. The unit must be used in a properly grounded wall outlet. Please read and follow the safety information listed below. /_Electrical Safety _ _'_ This dehumidifier is designed for indoor use only Do not use the unit near bath tubs, swimming pools or other bodies of water • Do not wet the housing or control panel • Do not exceed the power outlet ratings • Do not pull the unit by the cord • Always turn the unit off and unplug it from the outlet when cleaning • Unplug the unit if it is not going to be used for an extended time period • Do not operate the unit with a power plug missing the ground plug, a damaged cord or a loose socket • Be sure the dehumidifier is properly grounded • Never plug or unplug the unit with wet hands • Do not bypass, cut or remove the grounding plug • Do not use extension cords or power strips with this unit You may need to contact your electrician if it is necessary to use a longer cord or do not have a grounded outlet Do not modify the power cord's length or share the outlet with other appliances It is recommended the unit be connected on its own circuit • Do not start or stop the unit by switching the circuit's power on and off • If the power cord is damaged, it must be replaced by the manufacturer or a qualified technician • Never open the unit while it is plugged in • Immediately unplug the unit if it makes strange sounds, emits smells or smoke comes out of it, and contact customer _. service j /_General Safety This unit is not intended to be used by children Children should be supervised to ensure that they do not play with this product Do not allow children to play with the controls or drop any objects into the air outlets or vents • Care should be taken when using the unit in a room with infants, elderly persons, and children • Do not place flower vases, containers, or any objects on top of the unit • Do not allow anyone to sit on the unit • Do not climb on or use the unit as a step • Do not cover the air intake or exhaust vents with towels, clothes or materials that prevent air flow • When using in closets or confined spaces, be sure to keep doors open to allow proper ventilation • Do not use this appliance near flammable gas or combustibles, such as gasoline, benzene, thinner, etc • Do not use in areas where chemicals are handled • Do not place the unit near a heat source as doing so may cause the plastic parts to melt • Only use in an upright position on a flat, level surface and provide at least 10 inches of clearance from any walls or objects • Route the power cord carefully to avoid creating a tripping hazard • When using in closets or confined spaces, be sure to keep doors open to allow proper ventilation • Clean the filters every two weeks or as The wafer produced by the dehumidifier \._:_/ is not potable or suitable for drinking. 21 Do not drink or use condensate or wafer drained from the unit as if contains contaminates and could make you sick Electrical products should not be disposed of with household waste Please contact your local recycling center for more information on how to recycle electronic waste

IMPORTANT SAFETY INFORMATION ................................................................. I INTRODUCTION ................................................................................................... 1 PARTS IDENTIFICATION ..................................................................................... 2 BACK VIEW .......................................................................................................... 2 FRONT VIEW ......................................................................................................... 2 INSTALLATION INSTRUCTIONS ........................................................................ 3 CONTROL PANEL OVERVIEW ............................................................................ 4 OPERATING THE CONTROL PANEL ................................................................. 5 POWER ................................................................................................................ 5 A uto-Restart: ................................................................................................ 5 Auto-Shut Off: .............................................................................................. 5 CONTINUOUS MODE ............................................................................................. 5 FAN SPEEDS.......................................................................................................... 5 SETTING THE HUMIDITY LEVEL ................................................................................... 5 LCD DISPLAY ....................................................................................................... 6 Error Codes .................................................................................................. 6 WATER FULL LIGHT ................................................................................................. 6 ADDITIONAL NOTES ABOUT THE DEHUMIDIFIER'S BEHAVIOR: ......................................... 6 DRAINING THE UNIT ............................................................................................ 7 MANUAL DRAIN .................................................................................................... 7 CONTINUOUS DRAIN ............................................................................................. 7 MAINTENANCE .................................................................................................... 8 CLEANING THEUNIT ............................................................................................... 8 CLEANING THEPRE-FILTER....................................................................................... 8 CLEANING THEWATER BUCKET ................................................................................ 8 PREPARATION FOR STORAGE .................................................................................. 9 ENERGY SAVING GUIDE ..................................................................................... 9 TROUBLESHOOTING .......................................................................................... 9 SPECIFICATIONS ............................................................................................... 12 EdgeStar Portable Dehumidifier ii

this EdgeStar portable dehumidifier. We are glad you chose us. We believe fhaf your purchase of this product opens a relationship between you and EdgeSfar. We will provide the customer support needed fo nurture fhaf relationship. This manual contains important information regarding the proper installation, use and maintenance of your portable dehumidifier. Following this manual will ensure that your product will work at its peak performance and efficiency. Your dehumidifier is designed to remove moisture in the air by condensation removal and collecting the wafer in a removable bucket, or draining into a drain hose fhaf can be routed fo a drain hole on the floor or condensate pump. Please save the original product packaging in case you need to safely transport your portable dehumidifier. For Your Records: Please write down the model number and serial number below for future reference. Both numbers are located on the ratings label on the back of your unit and are needed fo obtain warranty service. You may also want fo staple your receipt fo this manual as if is the proof of your purchase, and is also needed for service under your warranty. Model Number: Serial Number: Date of Purchase: To better serve you, please do the following before contacting customer service: • If you received a damaged product, immediately contact the dealer that sold you the product. • Read and follow this instruction manual carefully to help you install, use and maintain your portable dehumidifier. • Read the troubleshooting section of this manual as it will help you diagnose and solve common issues. • Register your product at http://www.edgestar.com and download product guides, owner's manuals, and access additional troubleshooting resources. • If you need warranty service, our friendly customer service representatives are available via email af [email protected] or by telephone af 1 (866) 319-5473.

Parts Identification Front View Control Panel Air Intake Water Bucket Water Level Indicator Handle Back View Exhaust Drain Plug Power Plug Casters EdgeStar Portable Dehumidifier 2

basement will have little or no effect on adjacent enclosed rooms such as closets, unless there is enough circulation of air in and out of the enclosed area. The unit is designed to work in environments with temperatures between 41°F and 9qOF Your dehumidifier will remove moisture from the air and collect the excess wafer in a bucket. You can use the EdgeSfar dehumidifier fo create a comfortable environment and prevent damage caused by moisture fo books or valuables in areas such as basements or home libraries. Follow the instructions below fo unpack and set up your unit. 1) Carefully unpack the dehumidifier from its box and packaging material, and remove the adhesive tape holding the wafer bucket and filter in place. You may want fo save the box for storing and transporting the unit. Let the unit sit upright for af least 24 hours before powering if on fo allow the compressor's fluids fo settle. 2) Place the dehumidifier on a level floor or surface that is strong enough fo support the unit with a full bucket of wafer in a room where the ambient temperature will not drop below 41°F, and away from any heat sources such as direct sunlight, heaters, radiators, dryers, etc. Allow at least 10 inches of space all around the unit and at least 20 inches of space above the unit. 20 10_ f Caution: The unit is designed to be used indoors and freestanding, and not be used outdoors, or be built-in fo a cabinet or used under a counter. If you have multiple power outlets in the room, choose one that is near the dehumidifier and fhaf will be able fo provide adequate power fo the unit. See the power requirements listed on the product label printed on the side, or on the back of your dehumidifier. 3) Close all windows and doors. To be most effective, use the dehumidifier in a contained room. For example, use if in a room with four walls and a ceiling, instead of a partitioned studio, or warehouse. 4) To activate the unit and ensure the warning switches are engaged, remove the water bucket and reinstall it; otherwise, the unit may not work properly. 5) Plug the unit in to a grounded outlet. (Read the Safety Information section.) 6) When first using the unit, press the Power button on the top of the unit and run if in continuous mode for 24 hours.

Filter o Ful cD Cont. c] Turbo o Normal cY_ On Off Autodeffost c_ c_ o Timer Note: The unit is not a humidifier; using the increase humidify button will not add moisture fo the air. Button Function The check filter feature is a reminder fo clean the air filter for a more efficient operation. The Filter light will illuminate after 250 hours of operation. To reset after cleaning the filter, press the Filter button and the indicator light will shut off. (_ ets the unit fo run continuously until the wafer bucket is full. You will not be able fo use the increase/decrease humidify buttons. Sets the fan speed from normal fo turbo for your desired level of moisture removal. Powers the unit on or off. (_ Increases the desired relative humidify setting for damper air. Decreases the desired relative humidify setting for drier air. Press to initiate the auto start and auto stop feature in conjunction with the increase and decrease buttons. Indicator Light Function Filter Lights up to indicate the filter needs to be cleaned. The water full light will light up red if the unit has filled Full the water bucket. Cont. Lights up when the unit is set to run continuously until the water bucket is full. On/Off Lights up to indicate if the unit isin on or off position. Turbo Lights up to indicate the fan is on the high setting. Normal Lights up to indicate the fan is on the low setting. Auto-Defrost Lights up to indicate the auto defrost operation is on LCD Display Displays the level of humidity as well as error codes. EdgeStar Portable Dehumidifier 4

button to turn the portable dehumidifier on and off. By default when you first use the power button, the unit will begin fo operate in normal fan speed mode. Note: If the unit was powered off, waif af least 3 minutes before powering if back on. Auto-Restart: If power fo the unit is interrupted, the dehumidifier will restart itself in with the last used mode/settings once the power is restored. The compressor will restart after 3 minutes. Auto-Shut Off: The unit will shut off when the set humidify has been reached, or when the wafer bucket is full, has been removed, or is not in its proper position. Continuous Mode Continuous mode dehumidifies the air until the wafer bucket is full. Use the continuous mode for maximum dehumidification. You will not be able fo use the set humidify buttons. To operate the unit in continuous mode: 1) Make sure the power cord is plugged into a power outlet. 2) Press the "Power" button. 3) Press the "Conf." button. The LED indicator next fo "Conf." will light up. 4) Select the fan speed by using the Normal or High button. Fan Speeds The dehumidifier has two fan speeds. Use the turbo fan speed for maximum moisture removal. Use the normal fan speed for quieter operation. Select the fan speed by pressing the "Fan" button until desired mode is illuminated Setting the Humidity Level f Note: Relative Humidity (RH)is the ratio of the actual wafer content of the air at a given temperature to the potential water content af fhaf same temperature. The desired humidify level can be set within a range of 35% Relative Humidify (RH) fo 80% RH in 5% increments. To set the desired humidify level percentage: ]) Make sure the power cord is plugged into a power outlet. 2) Press the Power button. Make sure the "Conf." light is fumed off. 3) Press the "Increase" and "Decrease" buttons fo set the desired humidify level. After a few seconds, the LCD display will revert fo the acfuat room humidify level with +5% accuracy. For drier air use the "Decrease" button.

Operating the Control Panel continued The LCD Display will show the room's relative humidity percentage by default. Pressing the Increase and Decrease buttons will show the set humidity for a few seconds, and then revert to the room's relative humidity. Error Codes In addition to showing the humidify, the display may show the following error codes: AS - Humidity sensor error Power the unit off, and then unplug the unit for 15 minutes. Plug in and power on. If the issue persists, please contact customer service. ES- Temperature sensor error Power the unit off, and then unplug the unit for 15 minutes. Plug in and power on. If the issue persists, please contact customer service. EC - Unit malfunction Please make sure whether the ambient temperature is suitable for the stated temperature in the manual or not. If not, please operate the unit under the stated temperature. If the environment temperature is suitable for the stated temperature, please contact customer service. P2- Bucket is full Empty the water bucket and reinstall it. The Water Full Light will illuminate when the bucket is ready to be emptied. The light also turns on when the bucket is not installed or installed incorrectly. Once the wafer is drained, and the bucket is properly installed, the unit will operate normally. Additional notes about the dehumidifier's behavior: • Once the unit reaches the desired set humidify, the power button will remain lit while the compressor and fan shuts off. You will not be able fo change the fan speed. • If the power fo the unit was interrupted while the compressor was running, the unit may take a few minutes to start the fan and compressor. • If the room's relative humidity is lower than the set humidity, the unit will not start the fan and compressor unless you set the unit to run in Continuous mode. EdgeStar Portable Dehumidifier 6

bucket. When the bucket is full, the unit will automatically stop running, and the wafer full light will turn on. Follow the steps fo remove the bucket and dump the wafer. @ Warning: The wafer produced by the dehumidifier is not potable or suitable for drinking. 1) Slowly and carefully pull the bucket out by the handles until you see the bucket handle. 2) Pull the bucket up by its handle Do not drink the wafer drained from the unit as if contains contaminates and could make you sick. 3) Pour the water out. Do not place the bucket on the floor as its bottom is uneven and will fall down. 4) Reinstall the bucket. Continuous Drain The dehumidifier can be drained continuously fo a floor drain. ]) Remove the water bucket from the unit, and you will find a hose connector. You can use a ]2 mm hose fo attach fo the connector. Connector / Drain hose 2) Remove the rubber plug from the back of the unit's drain hose outlet, and push the drain hose through. 3) Securely attach the drain hose fo the connector. Lead the other end of the hose fo a floor drain or other suitable drainage port. 4) You must reinstall the wafer bucket.

unplug the dehumidifier from the power outlet before cleaning. Use a soft dry cloth to wipe the body clean. If necessary, use lukewarm water to dampen a cloth to clean the unit. Use a soft bristle brush and vacuum cleaner to clean between the air intake and exhaust vents. Never use abrasive chemicals, volatile substances, gasoline, detergents, chemically treated cloths, or other cleaning solvents that may damage the cabinet exterior. Never spray water directly on the unit. Cleaning the pre-filter Clean the pre-filter periodically to prolong the unit's life, and keep the unit running efficiently. Lint, dust, and dirt can clog the unit and reduce its performance and effectiveness. If the unit is used in a dusty environment you may need to clean it on a weekly basis. To clean the pre-filter, follow the steps below: 1) Power off the unit and remove the pre-filter. -ZT ................................................ ZZ "Z'ZI-ZZZi [ NOTE: Do not put the filter in a dishwasher. 2) Use a vacuum cleaner or tap the filter lightly to remove loose dust and dirt, then rinse thoroughly under lukewarm running water (below 104°F). You may use a mild soap and water solution if needed. Allow the pre-filter to air dry in a cool and shaded place. Dry thoroughly before reinstalling. 3) Reinsert the pre-filter. Warning: Never operate the unit without the air filter. Cleaning the water bucket Wash the water bucket frequently to prevent the growth of bacteria, mildew and mold. NOTE: Do not put the wafer bucket in a dishwasher. To clean the water bucket, follow the steps below: 1) Remove the wafer bucket from the unit. 2) Wash the bucket with clean wafer and a mild detergent. Rinse the bucket thoroughly. 3) Install the wafer bucket. EdgeStar Portable Dehumidifier 8

to be using fhe unif for an exfended period of time, follow fhe insfrucfions below before sforing your unif: ]) Turn off fhe unif and waif 24 hours before empfying fhe wafer lank. 2) Drain all fhe wafer from fhe wafer lank. 3) Clean fhe air filler, wafer lank and unif. 4) Unplug and carefully wind fhe power cord. 5) Cover fhe unif wifh a plastic bag. 6) Sfore fhe unif in an uprighf position in a dry, well-venfilafed place. Energy Saving Guide Read and follow fhe guide below fo gel fhe besf performance and efficiency from your porfable dehumidifier: • Do nor cover fhe air ouflef (exhausf) while in use. • Do nor place fhe unif in fronf of curfains or drapes- fo ensure fhey do nor obsfrucf fhe air infake. • Keep curfains, blinds or drapes closed during fhe sunniesf parr of fhe day. • Close all windows and doors. • Indoor relative humidify should ideally be kepf befween 35 and 60 percenf depending on fhe ambienf femperafure. • Make sure fhe unif is on a level surface. • To prolong fhe compressor's life, please waif af leasf 3 minufes before fuming fhe unif back on affer shuffing if off. • Inspecf and keep fhe pre-filfers clean by cleaning regularly. • Perform roufine mainfenance.

chart fo resolve common issues. Issue My dehumidifier does not dry the air Frost appears on the coils My dehumidifier is not functioning at all My dehumidifier is making a loud noise My dehumidifier is making a continuous metallic knocking or pinging sound Possible Cause Insufficient time fo dry Air intake or Exhaust vents are blocked Humidify control may not be set low enough Opened windows or doors Room temperature is too low (below 41°F) There is a kerosene heater or something giving off wafer vapor in the room This is normal behavior Unit is not receiving power Insufficient power Water bucket is full Water bucket is not in proper position Control panel is disconnected The unit is not level A foreign object has jammed the fan The floor below the unit is uneven Air filter is clogged Unit may have been shipped on its side Damaged compressor Solution Run the unit for a longer period of time. Make sure there are no towels, curtains, or furniture blocking the front and back of the unit. Lower the humidify control. Run the unit in continuous mode. Close all windows and doors. Increase the room temperature. Remove any device producing wafer vapor. The dehumidifier has an auto-defrost feature. Make sure the unit is plugged in. Move the unit fo another outlet. Check your circuit breaker. (Refer fo the rating label on the back of the unit fo determine the Amperage draw). Drain the unit and restart. Remove bucket and reinserf. If no indicator lights turn on, contact customer service. Make sure the unit is on a level surface. Shut off the unit, and remove the object from the fan. Move the unit fo a level surface. Clean the air filter. Shut off the unit. Let the unit sit on a level surface for af least 24 hours and restart. Contact customer service. EdgeStar Portable Dehumidifier 10

and then it trips the power cord or the circuit breaker The control panel lights blink randomly Unit has an AS error Unit has an ESerror Unit has a EC error Unit has a P2 error A drain hose has been attached and is loose Cracked water bucket The dehumidifier may be plugged into an outlet that can not supply the correct amount of current Unit may have a faulty control panel Humidify sensor error Temperature sensor error Unit malfunction Bucket is full Bucket is not correctly installed Secure the drain hose. Route your drain hose to a drain hole or condensate pump. Contact custom.er service. Contact an electrician if the unit works in a different room or circuit. Restart the unit, and if issue persists, contact customer service. Restart the unit, and if issue persists, contact customer service. Restart the unit, and if issue persists, contact customer service. Make sure the ambient temperature is suitable for the unit (41°F - 95°F). If not please operate the unit under the stated temperature. If the ambient temperature is suitable, please contact customer service. Empty the bucket and reinstall. Remove the bucket and reinstall. 11

50 Pints/Day R410A 15 3/8" x 10 9/16" x 23 1/8" 36 Ibs. EdgeStar Portable Dehumidifier 12

(90) Days Labor This product is warranted by EdgeStar to be free from defective workmanship and materials, subject to any conditions set forth as follows: WHAT IS COVERED: LABOR: For a period of NINETY (90) DAYS from the date of original purchase, labor will be performed free of charge at an authorized EdgeStar repair facility. At its option, EdgeStar will repair the product with new or remanufactured parts, or exchange the defective product with a new, refurbished, or remanufactured product. If a product is replaced, it will carry the remaining warranty of the original product. After the ninety (90) day period, EdgeStar will no longer be responsible for labor charges incurred. All defective products and parts covered by this warranty will be repaired or replaced on a mail-in basis to an EdgeStar authorized repair facility. PARTS: For a period of ONE (1) YEAR from the date of original purchase, EdgeStar will supply new, rebuilt, or refurbished parts free of charge. EdgeStar may request a defective part be returned in exchange for the replacement part. All replacement parts or products will be new, remanufactured, or refurbished. All products and parts replaced by EdgeStar under warranty service become the property of EdgeStar. This warranty applies to the original purchaser only, and only covers defects in workmanship experienced during operation of the product under normal service, maintenance, and usage conditions. This warranty applies to the purchase and use of this product in residential settings within the United States of America. WHAT IS NOT COVERED: The following limitations apply to the coverage of this warranty. This warranty does not cover: ,, Labor charges for installation, setup or training to use the product. ,, Shipping damage, and any damage caused by improper packaging for shipment to an authorized service center, and any damaged caused by improper voltage or any other misuse, including abnormal service, handling, or usage. ,, Cosmetic damage such as scratches and dents. ,, Normal wear and tear on parts or replacement of parts designed to be replaced, e.g. filters, cartridges, batteries. ,, Service trips to deliver, pick-up, or repair, install the product, or to instruct in proper usage of the product. ,, Damages or operating problems resulting from misuse, abuse, operation outside environmental specifications, uses contrary to instructions provided in the owner's manual, accidents, acts of God, vermin, fire, flood, improper installation, unauthorized service, maintenance negligence, unauthorized installation or modification, or commercial use. ,, Labor charges incurred 91 days or more after the date d original purchase. ,, The use of EdgeStar products in commercial settings. ,, Optional accessories, attachments, and appearance items. ,, Products that have been modified to perform outside of specifications without the prior written permission of EdgeStar. • Products lost in shipment, or theft. ,, Products sold AS IS or from an unauthorized reseller. ,, Products that have had their serial numbers removed or defaced. Products with serial numbers that have been invalidated. OBTAINING WARRANTY SERVICE: If you believe your product is defective, contact EdgeStar Customer Support for troubleshooting assistance and warranty service at 1-866-319-5473. Please have your serial number and proof of purchase available. Once an EdgeStar authorized representative has confirmed that your product is defective and eligible for warranty service, the product must be returned to an EdgeStar repair facility. The purchaser is solely responsible for prepaying all shipping related costs to and from the repair facility. EdgeStar is not responsible for damage resulting from shipper mishandling or improper packaging. Do not return a defective product to the place of purchase. Products received without a return authorization number will be refused. THIS WARRANTY IS IN LIEU OF ANY OTHER WARRANTY, EXPRESS OR IMPLIED, INCLUDING WITHOUT LIMITATION, ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. TO THE EXTENT ANY IMPLIED WARRANTY IS REQUIRED BY LAW, IT IS LIMITED IN DURATION TO THE EXPRESS WARRANTY PERIOD ABOVE. NEITHER THE MANUFACTURER NOR ITS DISTRIBUTORS SHALL BE LIABLE FOR ANY INCIDENTAL, CONSEQUENTIAL, INDIRECT, SPECIAL, OR PUNITIVE DAMAGES OF ANY NATURE, INCLUDING WITHOUT LIMITATION, LOST REVENUES OR PROFITS, OR ANY OTHER DAMAGE WHETHER BASED IN CONTRACT, TORT, OR OTHERWISE. SOME STATES DO NOT ALLOW THE EXCLUSION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS. YOU MAY HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE. EdgeStar Beverage Cooler

Austin, TX 78746 Toll Free: 1-866-319-5473 Web: http://www.edgestar.com E-mail: [email protected] Register your product, download owner's manuals, access additional troubleshooting resources, and obtain more information on other great EdgeStar & Koldfront products on the web at: http://www.edgestar.com Product contents and specifications may change without notice. Copyright © 2012 Living Direct, Inc. All rights reserved.