Teac PL-D2000 Service Manual

Effective : April, 2002 S-0057A NOTES ●PC boards shown are viewed from parts side. ●The parts with no reference number or no parts number in the exploded views are not supplied. ●As regards the resistors and capacitors, refer to the circuit diagrams contained in this manual. ●£ Parts marked with this sign are safety critical components. They must be replaced with identical components - refer to the appropriate parts list and ensure exact replacement. ●Parts of [ ] mark can be used only with the version designated. [J]:JAPAN [US]:U.S.A. [C]:CANADA [HK]:HONG KONG [SG]:SINGAPORE [E]:EUROPE [K]:KOREA [UK]:U.K. [SAF]:SOUTH AFRICA [NZ]:NEW ZEALAND [F]:FRANCE 注　　意 ●プリント基板図は部品面を示しています。 ●分解図に部番のない部品および品番のない部品は供給できま せん。 ●標準の抵抗、コンデンサーは省略してあります。 回路図を参照してください。 ●£印は安全重要部品です。 交換する時は必ず指定の部品を使用してください。 ●仕向先 [J]:JAPAN [US]:U.S.A. [C]:CANADA [HK]:HONG KONG [SG]:SINGAPORE [E]:EUROPE [K]:KOREA [UK]:U.K. [SAF]:SOUTH AFRICA [NZ]:NEW ZEALAND [F]:FRANCE

－2－ This product has been designed and manufactured according to FDA regulations "title 21, CFR, chapter 1, subchapter J, based on the Radiation Control for Health and Safety Act of 1968", and is classified as a class 1 laser product. There is no hazardous invisible laser radiation during operation because invisible laser radiation emitted inside of this product is completely confined in the protective housings. The label required in this regulation is shown 1. OCAUTION USE OF CONTROLS OR ADJUSTMENT OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. Optical pickup: Type : HOP-1000 Manufacturer : Hitachi Media Electronics Co., Ltd. Laser output : Less than 0.5 mW on the objective lens Wavelength : 770 - 810 nm (CD), 635 - 665 nm (DVD) 1 For U.S.A. CONTENTS 1 SAFETY INFORMATION ・・・・・・・・・・・・・・・・・・・・・・2 SAFETY INFORMATION 2 SPECIFICATIONS ・・・・・・・・・・・・・・・・・・・・・・・・・・・・・3 仕様 3 ADJUSTMENT AND CHECKS ・・・・・・・・・・・・・・・・5 調整と確認 4 EXPLODED VIEWS AND PARTS LIST ・・・・・・・・8 分解図とパーツリスト 5 PC BOARDS AND PARTS LIST ・・・・・・・・・・・・・・15 基板図とパーツリスト 6 BLOCK DIAGRAM ・・・・・・・・・・・・・・・・・・・・・・・・・・・23 ブロック図 7 WIRING DIAGRAM ・・・・・・・・・・・・・・・・・・・・・・・・・・・24 結線図

Signal system: NTSC / PAL Video signal horizontal resolution: More than 480 lines (DVD) Video signal-to-noise ratio: More than 60 dB (DVD) Audio frequency response (at 2 CH stereo mode): DVD (PCM): 2 Hz ~ 22 kHz (+/- 1.0 dB) CD: 2 Hz ~ 20 kHz (+/- 1.0 dB) Audio signal-to-noise ratio: More than 80 dB Total harmonic distortion: Less than 0.01% Dynamic range: DVD (PCM): More than 85 dB (2kHz, -60 dBFS) CD: More than 85 dB FM Tuner System: PLL quartz-locked digital synthesizer system Tuning range: 87.50 ~ 108.00 MHz (50 kHz step-European Model) 87.50 ~ 108.00 MHz (100 kHz step-General Export Model) Antenna: FM pigtail antenna Antenna terminals: 75 ohms, unbalanced Intermediate frequency: 10.7 MHz AM Tuner System: PLL quartz-locked digital synthesizer system Tuning range: 522 ~ 1620 kHz (9 kHz interval) (European Model) 530 ~ 1710 kHz (10 kHz interval) (General Export Model) Antenna: AM Loop antenna Video outputs CVBS Video: 1 Vp-p 75 ohms S-video: Y: 1 Vp-p 75 ohms C: PAL 0.3 Vp-p 75 ohms / NTSC 0.286 Vp-p 75 ohms Audio line outputs Audio L/R: 2 Vrms, 1 kilohms Subwoofer: 5 Vrms maximum (adjustable), 1 kilohms Audio power outputs Stereo mode: 20 W + 20 W (4 ohms at 1 kHz, THD 10%) Surround mode: Front: 20 W + 20 W (4 ohms at 1 kHz, THD 10%) Center: 20 W (4 ohms at 1 kHz, THD 10%) Rear: 20 W + 20 W (4 ohms at 1 kHz, THD 10%) • Phones: Accepts low- and high-impedance headphones Speakers Active Subwoofer: Power: 50 W (4ohms at 80 Hz, THD 10%) Speaker system: Bass reflex Speaker unit: 8 inches, dia. cone type Rated impedance: 4 ohms Dimensions: W160 x H333 x D222 mm Weight: 5.0 kg Front / Center / Rear speakers: Power: 20 W maximum Speaker system: Bass reflex Speaker unit: 2 7/8 inches, dia. cone type Rated impedance: 4 ohms Dimensions: W99 x H105 x D100 mm Weight: 0.8 kg General Power requirements: 120V AC, 60 Hz (General Export Model) 230 V AC, 50 Hz (European Model) 240 V AC, 50 Hz (Australian Model) Power consumption: 250 W Dimensions: W417 x H68 x D355 mm Weight: 8.5 kg Operating temperature: 5 ˚C ~ 40 ˚C Operating humidity: 5% ~ 90% Storage temperature: -20 ˚C ~ 55 ˚C Supplied accessories: AM loop antenna x 1 FM antenna x 1 Speaker cable (5m x 3, 10 m x 2) RCA cable (for Subwoofer) x 1 Stickers to protect speakers x 1 Remote control unit x 1 Batteries (AA, R6, SUM-3) x 2 • Design and specifications are subject to change without notice. • Weight and dimensions are approximate.

90mmx130mmx100mm(サランネット含む) 質量..............................フロント/センター：0.7kg, リア：0.5kg ■サブウーハー ユニット................................................................................165mm 最大出力..................................................75W(10% THD, 80Hz) 電源..................................................................100V AC 50-60Hz 消費電力......................................................................................25W 外形寸法(W x H x D)......................200mmx330mmx320mm 質量............................................................................................7.0kg ■付属品 リモコン リモコン用乾電池(単3)x 2本 AMループアンテナ FMアンテナ スピーカーケーブル(5m×3本, 10m×2本) サブウーハー用ケーブル(RCA)×1本 スピーカー用滑り止め×1シート 取扱説明書 保証書 仕様及び外観は改善のため予告なく変更することがあります。 ■本体 電源..................................................................100V AC 50-60Hz 消費電力.................................................................................. 160W 外形寸法(W x H x D)........................ 430mmx78mmx383mm 質量............................................................................................ 8.1kg 許容動作温度............................................................＋5℃～＋40℃ 許容動作湿度......................................5％～90％(結露のないこと) 許容保管温度..........................................................－20℃～＋55℃ アンプ部 ステレオ出力(10% THD, 1kHz, 4Ω) フロント..................................................................25W+25W サラウンド出力(10% THD, 1kHz, 4Ω) フロント..................................................................25W+25W センター................................................................................25W リア..........................................................................25W+25W 音声出力(ライン) AUDIO OUT ........................................................2Vrms, 1kΩ SUBWOOFER ..................................最大5Vrms(可変), 1kΩ DVDプレーヤー部 レーザー..................................................セミコンダクターレーザー 信号方式..........................................................................NTSC/PAL 周波数特性(2CH STEREOモード) DVD(PCM) ....................................20Hz～22kHz(±1.0dB) CD....................................................20Hz～20kHz(±1.0dB) SN比..........................................................................80dB(AUDIO) 60dB(VIDEO) 全高調波歪率....................................................................0.03％以下 ダイナミックレンジ DVD(PCM) ....................................85dB(2kHz, －60dBFS) CD ......................................................................................85dB ビデオ部 映像出力........................................................................1 Vp-p, 75Ω S映像出力 Y出力レベル........................................................ 1 Vp-p, 75Ω C出力レベル(NTSC)................................ 0.286 Vp-p, 75Ω C出力レベル(PAL) ........................................ 0.3 Vp-p, 75Ω コンポーネントビデオ出力(Y, CB, CR) Y出力レベル....................................................1.0 Vp-p, 75Ω CB出力レベル..................................................0.7 Vp-p, 75Ω CR出力レベル..................................................0.7 Vp-p, 75Ω チューナー部 受信周波数 FM ......................76.0MHz～90.0MHz(100kHzステップ) AM..............................522kHz～1,620kHz(9kHzステップ)

FM Signal Generator Oscilloscope VTVM(AC, DC) Test loop antenna (AW Adjustment) Dummy antenna (FM Adjustment) Stereo signal modulator Frequency counter Distortion analyser IMPORTANT 1. Check power-source voltage. 2. Set the function switch to band aligned. 3. Keep the signal input as low as possible to adjust accurately. 4. Modulation and modulation frequency. Item Modulation Modulation frequency Band AM 30% 400Hz FM 30%(22.5kHz Dev.) 1kHz ADJUSTMENT POINT 3 ADJUSTMENTS AND CHECKS 調整と確認

(FM, AM) DC VOLTMETER........................... CONNECT TO TEST POINT R109 and GND NO. Band Frequency Adjust for Adjustment 1 FM 87.50MHz [EUR,US] 76.00MHz [J] 1.5V 2 AM 522kHz [EUR,J] 530kHz [US] 1.5V T101 2.AM RF ADJUSTMENT　AM RF調整 Signal Generator........................ Connects to the AM ANT. Coil through the loop antenna. Adjust for the indication of VTVM of the wave form of scope to be maximum. BAND Step Frequency Adjust for Adjustment 1 612kHz [EUR,J] 610kHz [US] Maximum sensitivity L101 2 1404kHz [EUR,J] 1400kHz [US] Maximum sensitivity TC103 3 Repeat steps 1 and 2 several times. AM 108.00MHz [EUR,US] 90.00MHz [J] 8.4V 8.3V TC102 FM AM 3 4 1620kHz [EUR,J] 1710kHz [US] R109 GND

AC VOLT METER........................Connect to the output. Signal Generator........................Connect to FM ANT Jack (FM IN) through the dummy. Distortion Meter.........................Connect to the output. NO. Frequency Adjust for Adjustment 1 98.10MHz [EUR,US] 82.00MHz [J] FE001中周 Minimum T.H.D (<1%) 4.FM/AM AUTO STOP LEVEL CHECK　FM/AMオートストップレベル確認 FM SIGNAL GENERATOR ........................Connect to FM ANT Jack (FM IN) through the dummy AM SIGNAL GENERATOR.........................Connect to AM ANT, Coil through the Loop antenna BAND STEP SIGNAL GENERATOR Check Result 1 90.10MHz [EUR,US] 78.00MHz [J] ≦32dB OK/NG 2 106.10MHz [EUR,US] 88.00MHz [J] ≦32dB OK/NG 1 612kHz [EUR,J] 610kHz [US] ≦84dB OK/NG 2 1404kHz [EUR,J] 1400kHz [US] ≦84dB OK/NG AM FM TUNED TUNED TUNED TUNED AC

9A09197200 FRONT CAB [E,UK,F] 1- 4 9A07465300 PHONE JACK,BLK 1- 5 9A09137800 PHONE PCB ASSY 1- 6 9A09116600 WASHER,OD14XID3.2XT1.0MM 1- 7 9A09137700 KEY PCB ASSY 1- 8 9A08320700 R-ENCODER 1- 9 9A09116300 SCREW,T3.0XL8.0XP1.06MM 1-10 9A09125300 HEAT SINK 1-11 9A09115300 SPACER SUPPORT,L=18 1-12 9A09114800 RUBBER,DIA14XT3MM WHITE 1-13 9A09197900 PCB BKT 1-14 9A09115400 BOTTOM CAB 1-15 9A09125400 HEAT SINK 1-16 9A09113100 MAIN PCB ASSY [J,US,C,HK,SG,K,SAF,NZ] 9A09113140 MAIN PCB ASSY [E,UK,F] 1-17 9A09125500 HEAT SINK 1-18 9A09113200 TUNER PCB ASSY [J] 9A09113210 TUNER PCB ASSY [US,C] 9A09113220 TUNER PCB ASSY [HK,SG,K,SAF,NZ] 9A09113240 TUNER PCB ASSY [E,UK,F] 1-19 9A09129500 PCB BKT 1-20 9A09125600 BRACKET 1-21 9A09196800 BACK CAB [J] 9A09115600 BACK CAB [US,C] 9A09248800 BACK CAB [HK,SG,K] 9A09248900 BACK CAB [E,UK,SAF,F] 9A09249000 BACK CAB [NZ] 1-22 9A09115500 TOP COVER 1-23 9A09113800 PLASTIC BRACKET 1-24 9A09116000 SCREW,M3X6X0.5P 1-26 9A09116000 SCREW,M3X6X0.5P 1-27 9A09111100 SPONGE,L52XW5.5XT1.0MM 1-28 9A09116800 RUBBER PAD,L54XW20XT3.0MM 1-29 9A09125600 BRACKET 1-30 9A09116000 SCREW,M3X6X0.5P 1-31 £ 9A08289700 AC LINE BUSHING 1-32 £ 9A09198100 LINE CORD [J] £ 9A09117200 LINE CORD [US,C] £ 9A09249700 LINE CORD [HK,UK] £ 9A09249800 LINE CORD [E,SG,SAF,F] £ 9A09249900 LINE CORD [K] £ 9A09250200 LINE CORD [NZ] 1-33 9A09141000 PRO LOGIC+SCART PCB ASSY [J,US,C,HK,SG,K,NZ] 9A09141040 PRO LOGIC+SCART PCB ASSY [E,UK,SAF,F] 1-34 9A09141400 PCB BKT 1-35 £ 9A09198200 PWR TRANSFORMER,100V [J] £ 9A09133400 PWR TRANSFORMER,120V [US,C] £ 9A09249600 PWR TRANSFORMER,230V [HK,SG,E,K,UK,SAF,NZ,F]

£ 9A09117100 PWR TRANSFORMER,120V [US,C] £ 9A09197100 PWR TRANSFORMER,230V [HK,SG,E,K,UK,SAF,F] £ 9A09273600 PWR TRANSFORMER,240V [NZ] 1-37 9A09113000 MPEG PCB ASSY 1-38 9A09116100 SCREW,M3X8X0.5P 1-39 9A09117600 DVD LOADER,DSL-710A DVS A 1-40 9A09115700 BRACKET 1-41 9A09115800 BRACKET 1-42 9A09113500 POWER SW PROTECTOR 1-43 £ 9A09117000 SW,PUSH P12 1-44 9A07465600 LED,RED 1-45 9A09137900 LED PCB ASSY 1-46 9A09114100 POWER KNOB 1-47 9A09114900 LOGO PLATE 1-48 9A09114400 LED LENS 1-49 9A09114200 KNOB,STAND-BY KEY 1-50 9A09114800 RUBBER,DIA14XT3MM WHITE 1-51 9A09113600 DVD DOOR 1-52 9A09114600 TRANSPRENT DOOR 1-53 9A09114300 LCD LENS 1-54 9A09113900 FUN. KNOB INCLUDED ACCESSORIES REF.NO. PARTS NO. DESCRIPTION REMARKS 9A09053900 OWNER'S MNL,J [J] 9A09053800 OWNER'S MNL,E/F [US,C] 9A09053700 OWNER'S MNL,E/F/G/I/S [EXCEPT J] 9A09110000 REMOTE CONTROL UNIT,RC829 S/No. 10900000 and earlier 9A09110001 REMOTE CONTROL UNIT,RC829A S/No. 10900001 and after 9A09110400 BATTERY 9A09111500 WIRE,5000MM (BLU/BLK) 9A09111600 WIRE,10000MM (GRY/BLK) 9A09111700 WIRE,5000MM (RED/BLK) 9A09111800 CABLE,RCA (BLK) 9A09111900 CABLE,RCA (RED/YEL/WHT) 9A09109900 LOOP ANT ASSY 9A09112000 T ANTENNA 75 OHM [J,US,C] 9A09205600 T ANTENNA [HK,SG,E,K,UK,SAF,NZ,F]

9A09117000 SW,PUSH P12 2- 2 9A09143200 POWER KNOB 2- 3 9A09143700 LOGO PLATE 2- 4 9A09143400 SPK TRIM 2- 5 9A09140200 SW PCB ASSY 2- 6 9A09143000 SPK,CAB 2- 7 9A09145200 SCREW,T2.6XP1.07XL8.0MM 2- 8 9A09143900 PORT TUBE,OD65XID55XL155M 2- 9 9A09145600 SPONGE,OD118XID50XT10MM 2-10 9A09144100 WOOD BOX [EXCEPT J] 9A09197300 WOOD BOX [J] 2-11 9A09144200 SPK DRIVER,100W 6.5INCH 4OHM 2-12 9A09144600 SCREW,M3.5X14MM BLK 2-13 9A09143100 GRILLE 2-14 9A09145100 SCREW,M3X10 BLK 2-15 9A08755900 SCREW,T3.0XL8.0XP1.06MM 2-16 9A09146000 COVER SPONGE,L34XW4.5XT3MM 2-17 9A09142800 REAR COVER 2-18 9A09144600 SCREW,M3.5X14MM BLK 2-19 9A09197400 REAR PLATE [J] 9A09144400 REAR PLATE [US,C] 9A09249100 REAR PLATE [HK,SG,E,K,UK,SAF,F] 9A09249200 REAR PLATE [NZ] 2-20 9A09133600 JACK SWITCH PCB ASSY 2-21 9A09145300 FIBER,DIA12XID3.5XT1.6MM 2-22 9A09134100 AMP PCB ASSY 2-23 9A09142900 FOOT,D25XL25 2-24 9A09144700 SCREW,T4X20MM BLK [EXCEPT J] 9A09197600 SCREW,T4X25MM BLK [J] 2-25 9A09145400 RUBBER PAD,D20XT3MM BLK 2-26 £ 9A09274700 PWR TRANSFORMER,100V [J] £ 9A09146500 PWR TRANSFORMER,120V [US,C] £ 9A09274800 PWR TRANSFORMER,230V [HK,SG,E,K,UK,SAF,NZ,F] 2-27 9A09116500 NUT,M4.0XOD7.0XT3.0MM 2-28 9A09144300 BRACKET,X'FORMER 2-29 9A09143500 RUBBER PAD,50X12XT2MM 2-30 9A09144900 SCREW,M4X25X0.7MM BLK 2-31 £ 9A09143800 BUSHING 2-32 £ 9A07441300 LINE CORD [J] £ 9A09146600 LINE CORD [US,C] £ 9A09420200 LINE CORD [HK,UK] £ 9A09420300 LINE CORD [SG,E,SAF,F] £ 9A09420400 LINE CORD [K] £ 9A07469800 LINE CORD [NZ] 2-33 9A09143300 LED LENS

9A09118700 SPK DRIVER,25W 3INCH 4OHM (FRONT/CENTER) 3- 4 9A09118900 SPONGE,OD79XID70XT3.0MM 3- 5 9A09118000 SPK PANEL (FRONT/REAR) 9A09118100 SPK PANEL (CENTER) 3- 6 9A09119100 SPONGE,L123XW5XT1MM 3- 7 9A09117800 REAR COVER 3- 8 9A08755800 SCREW,T3.0XL10.0XP1.06MM 3- 9 9A09118300 SPK JACK,2P BLK-RED (FRONT) 9A09118400 SPK JACK,2P BLK-BLU (CENTER) 9A09118500 SPK JACK,2P BLK-GRY (REAR) 3-10 9A09118800 SCREW,T4X12MM BLK

1=INSTALL, 0=NOT INSTALL

REF.NO. PARTS NO. DESCRIPTION 9A09113100 MAIN PCB ASSY [J,US,C,HK,SG,K,SAF,NZ] 9A09113140 MAIN PCB ASSY [E,UK,F] 9A09128400 MAIN PCB 9A08773200 WASHER,ID=3 OD=6 H=2.5MM 9A09125300 HEAT SINK 9A08290700 MICA 9A09125600 BRACKET 9A09116000 SCREW,M3X6X0.5P 9A09116300 SCREW,T3.0XL8.0XP1.06MM C455 9A09125200 SLEEVING,OD2XID1XL5MM C905,C907 £ 9A08829500 C,ELECT 6800UF/25V 20% C926,C945 £ 9A08829400 C,ELECT 3300UF/25V 20% C935 £ 9A09126000 C,ELECT,2200UF/25V 20% CN001 9A08299800 CONNECTOR,TUC-P10P-B1 CN201 9A09124600 CONNECTOR,12PIN CN301 9A09124500 CONNECTOR,7PIN CN601A 9A09027100 CONNECTOR,TUC-P15P-B1 CN902 9A09124400 CONNECTOR,B9B-XH-A 9PIN CN903 9A07466200 CONNECTOR,CL3962WVO 3PIN CN904 9A08300100 CONNECTOR D401 9A07449400 DIODE,1N4148 D501-D504 9A07449400 DIODE,1N4148 D507-D510 9A07449400 DIODE,1N4148 D901 £ 9A09126700 RECTIFIER,KBU8B D906,D907 9A07466400 SLEEVING,OD3.0XID2.5XL10 D906,D907 £ 9A07462200 RECTIFIER,1N5401 D908,D909 £ 9A07461600 RECTIFIER,1N4001 D910 9A07466400 SLEEVING,OD3.0XID2.5XL10 D910 9A07462200 RECTIFIER,1N5401 D911,D912 £ 9A07461600 RECTIFIER,1N4001 D913-D916 9A07461600 RECTIFIER,1N4001 D917 9A09125200 SLEEVING,OD2XID1XL5MM D917 9A09126600 RECTIFIER,1N5392 F901,F902 9A07451800 FUSE CLIP F901,F902 £ 9A09125800 FUSE,6.3A 250V SLOW F905-F908 9A07451800 FUSE CLIP F905-F908 £ 9A09125700 FUSE,1.6A 250V SLOW IC401 9A09046500 IC,TC4052BFN IC402-404 9A09123800 IC,JRC4558D IC405,406 9A08824200 IC,TC4053BFN IC407 9A09123800 IC,JRC4558D IC408 9A09046300 IC,M62446FP IC409-411 9A09123800 IC,JRC4558D IC501-503 9A09126800 IC,TDA7265 IC901 £ 9A08825600 IC,7812 IC901,902 9A09125500 HEAT SINK IC902 £ 9A09127000 IC,7912 IC903 9A09125400 HEAT SINK IC903 £ 9A07463000 IC,MC7806ACT IC905 £ 9A09126900 IC,BA05T JK105 9A09125100 RCA JACK,1P BLK JK106 9A09124900 TOSLINK JACK,TOTX178A JK401 9A09124700 RCA JACK,6P WHT/RED JK402 9A09125000 RCK JACK,1P BLK MAIN PCB ASSY REF.NO. PARTS NO. DESCRIPTION JK501 9A09124800 SPK JACK,10P L501-L503 9A07464000 RF COIL,1UH L505,L506 9A07464000 RF COIL,1UH Q401-Q403 9A07461700 TR,2SC2878 Q404 9A07449500 TR,2SC945P Q501-Q503 9A07449500 TR,2SC945P Q504,Q505 9A07449600 TR,2SA733Q/P Q506 9A07449500 TR,2SC945P Q901 9A07450400 TR,2SC2001L Q905,Q907 9A07463800 TR,2SB772P/Q Q906,Q908 9A07461700 TR,2SC2878 Q909,Q911 9A07449600 TR,2SA733Q/P Q910,Q912 9A07449500 TR,2SC945P Q913 9A07449600 TR,2SA733Q/P Q914 9A07449500 TR,2SC945P R26-R28 9A09125200 SLEEVING,OD2XID1XL5MM R443,R448 9A09125200 SLEEVING,OD2XID1XL5MM R516-R519 9A09125200 SLEEVING,OD2XID1XL5MM R904,R908 9A09125200 SLEEVING,OD2XID1XL5MM R922 £ 9A09127500 R,33 OHM 1/2W 5% R925,R926 9A09125200 SLEEVING,OD2XID1XL5MM R925,R926 £ 9A09126400 R,1 OHM 1/2W 5% RB102 9A09124300 CONNECTOR,28P FFC ZD401,402 9A09045000 DIODE,ZENER 6.9-7.2V 0.5W ZD403,404 9A07461800 DIODE,ZENER 6.0-6.3V 0.5W KEY PCB ASSY (GATHER) REF.NO. PARTS NO. DESCRIPTION 9A09113400 KEY PCB ASSY [J,US,C] 9A09113420 KEY PCB ASSY [HK,SG,E,K,UK,SAF,NZ,F] KEY PCB ASSY 9A09137700 KEY PCB ASSY 9A09139500 KEY PCB CN202 9A08310300 CONNECTOR,B 4B-PH-K D201-D203 9A07449400 DIODE,1N4148 DP201 9A09138200 VFD IC201 9A09138600 IC,PT6311 SN201 9A09138700 IRT SENSOR TA202-210 9A09138300 SW,TACT VR201 9A08320700 R-ENCODER ZD201 9A09121800 DIODE,ZENER 4.1-4.3V 0.5W PHONE PCB ASSY 9A09137800 PHONE PCB ASSY C306,C307 9A07461700 TR,2SC2878 FB302,303 9A09121900 BEAD FERIT,3.5DIA X 6MM IC304 9A09139000 IC,TDA2822 JK301 9A07465300 PHONE JACK,BLK Q308 9A07450400 TR,2SC2001L ZD301 9A07461800 DIODE,ZENER 6.0-6.3V 0.5W LED PCB ASSY 9A09137900 LED PCB ASSY D204 9A07465600 LED,RED TA201 9A09138300 SW,TACT －20－

REF.NO. PARTS NO. DESCRIPTION 9A09113200 TUNER PCB ASSY [J] 9A09113210 TUNER PCB ASSY [US,C] 9A09113220 TUNER PCB ASSY [HK,SG,K,SAF,NZ] 9A09113240 TUNER PCB ASSY [E,UK,F] 9A09132300 TUNER PCB [EXCEPT J] 9A09197000 TUNER PCB [J] 9A09129500 PCB BKT 9A09132100 TUNER PACK [EXCEPT J] 9A09196900 TUNER PACK [J] CF101,102 9A09129700 CERAMIC FILTER,10.7MHZ CF103 9A09129600 CERAMIC FILTER,450KHZ CF104 9A09129900 CERAMIC FILTER,CDA10.7MG-18A CF105 9A09130000 RESONATOR,CRB456F18 D101-D105 9A07449400 DIODE,1N4148 IC101 9A09131400 IC,TA8132AN IC102 9A09131300 IC,TC9257F JK002 9A09129300 ANT JACK,BLK L101 9A09131800 ANT OSC,AM L103,L104 9A08305300 CHOKE,10UH L105,L106 9A09131600 CHOKE,39MH L142 9A08305300 CHOKE,10UH [EXCEPT J] L143 9A08305300 CHOKE,10UH [J] Q101,Q102 9A09133000 TR,2SC1675L Q103 9A07449500 TR,2SC945P Q104 9A07449600 TR,2SA733Q/P Q106,Q107 9A07449600 TR,2SA733Q/P Q108 9A09132900 FET,2SK192A-Y/GR Q109,Q110 9A07449500 TR,2SC945P RB101 9A08305600 CONNECTOR,TUC-P10X-B1 T101 9A09131900 OSC AM,108UH T102 9A09131700 IFT AM,455KHZ TC102 9A09130200 C,TRIM 4.2-20PF TC103 9A09130100 C,TRIM 3-10PF NP0 VD102,103 9A09131500 DIODE,1SV149B XL102 9A09129800 CRYSTAL,7.2000MHZ ZD101 9A09132500 DIODE,ZENER 3.8-4.0V 0.5W POWER PCB ASSY REF.NO. PARTS NO. DESCRIPTION 9A09113300 POWER PCB ASSY [J] 9A09113310 POWER PCB ASSY [US,C] 9A09113320 POWER PCB ASSY [HK,SG,E,K,UK,SAF,NZ,F] 9A09133100 POWER PCB £ 9A09198200 PWR TRANSFORMER,100V [J] £ 9A09133400 PWR TRANSFORMER,120V [US,C] £ 9A09249600 PWR TRANSFORMER,230V [HK,SG,E,K,UK,SAF,NZ,F] C951 £ 9A09133300 C,SAFETY 0.001UF/400V POWER PCB ASSY REF.NO. PARTS NO. DESCRIPTION C952,C953 £ 9A07464900 C,SAFETY 0.01UF 20% CN907,909 9A07464500 CONNECTOR,4PIN CN908 9A08297700 CONNECTOR,3PIN F903 £ 9A09026400 FUSE,3.15A 250V SLOW FOR F903 9A07442900 FUSE COVER FOR F903 9A07451800 FUSE CLIP R945 9A09125200 SLEEVING,OD2XID1XL5MM R945 £ 9A08298000 R,4.7M OHM 1/2W R946,R947 9A09125200 SLEEVING,OD2XID1XL5MM RL901 £ 9A09133200 RELAY,5VDC 40MA MPEG PCB ASSY REF.NO. PARTS NO. DESCRIPTION 9A09113000 MPEG PCB ASSY 9A09122000 MPEG PCB CN101 9A09120300 CONNECTOR,40P CN102 9A09120200 CONNECTOR,28P FFC CN103 9A08831500 CONNECTOR,S2B-XH-A 2P CN104 9A09120500 CONNECTOR,10P CN108 9A09120400 CONNECTOR,9P D101-D113 9A07449400 DIODE,1N4148 FB105 9A09121900 BEAD FERIT,3.5DIA X 6MM FB111,112 9A09121900 BEAD FERIT,3.5DIA X 6MM IC101,102 9A09120600 IC SOCKET,32P IC101,102 9A09121300 IC,F29C51004T-90PC IC103,104 9A09124000 IC,SDRAM 512KX2X16 IC105,106 9A09124100 IC,74HC374 IC107 9A09123700 IC,ES4408 IC108 9A09121200 IC,AT24C02 IC109 9A09123900 IC,CS4955-CQ IC110-112 9A09123600 IC,CS4340 IC113-119 9A09123800 IC,JRC4558D IC120 9A09046500 IC,TC4052BFN IC122 9A09046400 IC,TC74HC04AFN L103-L108 9A09121400 CHOKE,2.2UH L109 9A08305300 CHOKE,10UH Q102,Q108 9A07449500 TR,2SC945P Q107 9A07463500 TR,2SD882P R1095 9A09121700 R,2K 1/6W 1% R1096 9A09121700 R,2K 1/6W 1% XL101 9A09120700 CRYSTAL,27MHZ ZD101,102 9A09045000 DIODE,ZENER 6.9-7.2V 0.5W ZD103 9A09121800 DIODE,ZENER 4.1-4.3V 0.5W －21－

REF.NO. PARTS NO. DESCRIPTION 9A09141000 PRO LOGIC+SCART PCB ASSY [J,US,C,HK,SG,K,NZ] 9A09141040 PRO LOGIC+SCART PCB ASSY [E,UK,SAF,F] 9A09142000 PRO LOGIC+SCART PCB 9A09141400 PCB BKT 9A09116000 SCREW,M3X6X0.5P CN601 9A09042600 CONNECTOR,TUC-P15X-B1 IC601 9A09141600 IC,LV1035M IC602 9A09123800 IC,JRC4558D JK101 9A09141300 JACK RCA,RED/GRN/BLU JK103 9A09141500 RCA JACK,1P YELLOW JK104 9A09141200 DIN JACK,4PIN DSW-04 DVD L601 9A08305300 CHOKE,10UH Q601 9A07450400 TR,2SC2001L Q603,Q604 9A07461700 TR,2SC2878 XL601 9A08305800 RESONATOR,8MHZ ZD601 9A08820300 DIODE,ZENER 9.1-9.5V 0.5W JACK SWITCH PCB ASSY [SUB WOOFER] REF.NO. PARTS NO. DESCRIPTION 9A09133600 JACK SWITCH PCB ASSY 9A09134000 JACK SWITCH PCB JK301 9A09125000 RCA JACK,1P BLK SW301 9A09133800 SW,SLIDE LED+SW PCB ASSY (GATHER) [SUB WOOFER] REF.NO. PARTS NO. DESCRIPTION 9A09140100 LED+SW PCB ASSY SW PCB ASSY 9A09140200 SW PCB ASSY C920 £ 9A07464900 C,SAFETY 0.01UF 20% SW920 £ 9A09117000 SW,PUSH P12 LED PCB ASSY 9A09140300 LED PCB ASSY D920 9A09140700 LED,ORG/GREEN AMP PCB ASSY [SUB WOOFER] REF.NO. PARTS NO. DESCRIPTION 9A09134100 AMP PCB ASSY 9A09136100 AUDIO AMP PCB 9A09134500 HEAT SINK 9A09028900 BRACKET 9A08755400 SCREW,M3.0XL8.0XP0.5 9A09134700 SCREW,T3.0XL12.0MM BLK BD901 £ 9A09135600 RECTIFIER,RS402L C905,C906 £ 9A08829600 C,ELECT 4700UF/50V 20% CN301 9A08300000 CONNECTOR,B 3B-PH-K CN401 9A08309300 CONNECTOR,B 2B-XH-A 2PIN CN501 9A09135900 WIRE TERM CN901 9A09134400 CONNECTOR,3P D401-D404 9A07449400 DIODE,1N4148 D501,D507 9A07461600 RECTIFIER,1N4001 D502-D504 9A07449400 DIODE,1N4148 D506 9A07449400 DIODE,1N4148 F901,F902 £ 9A09198300 FUSE,4A 125V SLOW F901,F902 9A07451800 FUSE CLIP IC401 9A08825400 IC,TL074CN L501 9A07464000 RF COIL,1UH Q401-Q404 9A07449500 TR,2SC945P Q501,Q502 9A07449500 TR,2SC945P Q504,Q505 9A07449500 TR,2SC945P Q506 9A07449600 TR,2SA733Q,P Q507,Q508 9A07449600 TR,2SA733Q,P Q509,Q510 9A07449500 TR,2SC945P Q511 9A07463900 TR,2SA965-Y Q512 9A07463600 TR,2SC2235-Y Q513 £ 9A09135800 TR,2SA1941-O Q513,Q514 9A09134600 MICA SHEET Q514 £ 9A09135700 TR,2SC5198-O Q515,Q518 9A07449600 TR,2SA733Q,P Q516,Q517 9A07449500 TR,2SC945P R513,R517 £ 9A09135300 R,0.22 OHM 5W 5% R520,R522 £ 9A07458200 R,4.7 OHM 1/2W R521 £ 9A09136300 R,3.9K OHM 1/2W 5% R525 £ 9A09135200 R,620 OHM 2W 5% R901 £ 9A09135400 R,470 OHM 2W 5% R902 £ 9A09135500 R,560 OHM 2W 5% RL501 9A09134900 RELAY,RPA-12V ZD501 9A08310000 DIODE,ZENER 11.9-12.4V 0.5W ZD502-504 9A09137000 DIODE ZENER 14.5-15.1V 0.5W －22－

ブロック図

BEFORE RETURNING APPLIANCE TO THE CUSTOMER, MAKE LEAKAGE- CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT.

BEFORE RETURNING APPLIANCE TO THE CUSTOMER, MAKE LEAKAGE- CURRENT OR RESISTANCE MEASUREMENTS TO DETERMINE THAT EXPOSED PARTS ARE ACCEPTABLY INSULATED FROM THE SUPPLY CIRCUIT.