Sony STR-V5500 Service Manual

MICROFILM STR-V5500 is RECEIVER section in MHC-V5500. SPECIFICATIONS Manufactured under license from Dolby Laboratories Licensing Corporation. “DOLBY”, “PRO LOGIC” and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation. Amplifier section Continuous RMS power output China model 100+100 watts 6 ohms at 1 kHz, 10% THD (240V AC supply) 85+85 watts 6 ohms at 1 kHz, 10% THD (220V AC supply) Other models 100+100 watts (6 ohms at 1 kHz,10% THD) Peak music power output 1500 watts (reference) Inputs MD/VIDEO 1 IN (phono jacks): voltage 250 mV, impedance 47 kilo ohms AV INPUT AUDIO (phono jacks): voltage 250 mV, impedance 47 kilo ohms MIX MIc 1/2 (phone jack): sensitivity 1 mVm, impedance 10 kilo ohms Outputs MD/VIDEO OUT (phono jacks): voltage 250 mV, impedance 1 kilo ohm PHONES (stereo phone jack): accepts headphones of 8 ohms or more. SPEAKER: accepts impedance of 6 to 16 ohms SUPER WOOFER: Voltage 1 V, impedance 1 kilo ohm Video section Inputs AV INPUT VIDEO (phono jack): 1 Vp-p, 75 ohms VIDEO IN (phono jack): 1 Vp-p, 75 ohms Outputs MONITOR OUT (phono jack): 1 Vp-p, 75 ohms VIDEO OUT (phono jack): 1 Vp-p, 75 ohms S-VIDEO (4-pin/mini- DIN jack): Y: 1 Vp-p, unbalanced, sync negative C: 0.286 Vp-p, load impedance 75 ohms Tuner section FM stereo, FM/AM superheterodyne tuner FM tuner section Tuning range 87.5-108.0 MHz Antenna terminals 75 ohm unbalanced Intermediate frequency 10.7 MHz AM tuner section Tuning range Thai models: 531-1,602 kHz (with the AM tuning interval set at 9 kHz) 530-1,710 kHz (with the AM tuning interval set at 10 kHz) Other models: MW 531-1,602 kHz (with the MW tuning interval set at 9 kHz) 530-1,710 kHz (with the MW tuning interval set at 10 kHz) SW 5.95-17.90 MHz (with the SW tuning interval set at 5 kHz) Intermediate frequency 450 kHz Antenna AM loop antenna External antenna terminal Design and specifications are subject to change withouto notice.

Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tentalum capacitor may be damaged by heat. TABLE OF CONTENTS 1. GENERAL ······································································ 3 2. TEST MODE ·································································· 5 3. DIAGRAMS 3-1. Circuit Boards Location ····················································· 6 3-2. Printed Wiring Board — Panel Section —························· 7 3-3. Schematic Diagram — Panel Section — ··························· 9 3-4. Printed Wiring Board — Main Section — ······················· 12 3-5. Schematic Diagram — Main Section — ·························· 15 3-6. Printed Wiring Board and Schematic Diagram — Power Section — ························································· 19 3-7. IC Pin Function ································································ 23 3-8. IC Block Diagrams ··························································· 24 4. EXPLODED VIEWS 4-1. Main Section····································································· 25 4-2. Panel Section ···································································· 26 5. ELECTRICAL PARTS LIST ··································· 27 SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

SECTION 1 GENERAL — FRONT PANEL — 1 KARAOKE PON/MPX button 2 SURROUND button 3 EFFECT ON/OFF button 4 MUSIC button 5 MOVIE button 6 GAME button 7 P FILE button 8 MEMO button 9 DBFB button !º VOLUME !¡ GROOVE button !™TUNER BAND button !£ STEREO/MONO button !¢ FUNCTION button !∞MIC LEVEL/ECHO VOL !§ MIX MIC 1 jack !¶ MIX MIC 2 jack !• PHONES jack !ª EDIT button @º PLAY MODE button @¡ 1/ALL DISCS button @™REPEAT button @£ HIGH FREQ button @¢ ENTER/NEXT button @∞MULTI JOG STATION dial @§ LOW FREQ button @¶ MEMORY button @• TUNING MODE button @ª FLASH button #º LOOP button #¡ WAVE button #™AV INPUT jack #£ CLOCK TIMER SET button #¢ TIMER SELECT button #∞KEY CONTROL ˜ button #§ KEY CONTROL n button #¶ DISPLAY/DEMO button #• POWER button 1 2 3 4 5 6 7 8 9 !º !¡ !™ !£ !¢ !∞ !§ !¶ !• !ª @º @¡ @™ @£ @¢ @¶ @∞ @§ @• @ª #º #¡ #™ #£ #¢ #¶ #• #§ #∞

— BACK PANEL — #ª ANTENNA terminal $º SYSTEM CONTROL $¡ MD/VIDEO 1 jack $™FRONT SPEAKER terminal $£ SUPER WOOFER jack $¢ VIDEO OUT jack $∞VOLTAGE SELECTOR switch #ª $º $¡ $™ $£ $¢ $∞

FL DISPLAY/KEY LED TEST MODE Press the REPEAT, ENTER/NEXT and SURROUND buttons simultaneously. 1. All FL segments and all LEDs turn on. 2. To access the microprocessor information, press the P FILE key. Each pressing of the P FILE key advances the display on the FL tube in the following sequence. 3. To check the encoder, press the MUSIC key. The following display appears on the FL tube. "K 0 J 0 V 0" The number after K indicates the number of times that the key is pressed. The key which was pressed in the past, is not counted. The key which is pressed hereafter is counted. Pressing any key increases the number after K. The number after J indicates the number of rotations that the JOG dial is rotated. Turning the JOG dial clockwise increases the number after J. Turning the JOG dial counter-clockwise decreases the number after J. The number after V indicates the number of rotations that the VOLUME dial is rotated. Turning the VOLUME dial clockwise increases the number after V. Turning the VOLUME dial counter- clockwise decreases the number after V. To exit this mode, perform the "Cold Reset" (reset clearing memory) as described below. GENERAL TEST MODE (INCLUDING AMPLIFIER AND TUNER) Press the REPEAT, ENTER/NEXT and CLOCK TIMER SET buttons simultaneously while the main power is on. 1. Sound volume display segment starts blinking. 2. The tuning enters the PRESET mode. 3. Rotating the VOLUME control clockwise increases the volume level to maximum. Rotating the VOLUME control counter-clockwise decreases the volume level to minimum. 4. Pressing the MUSIC key decreases the equalizer curve to minimum and "EQ CHECK" appears on the display. Pressing the MOVIE key increases the equalizer curve to maximum. Pressing the GAME key makes the equalizer curve flat. 5. Pressing any of the DBFB, GROOVE or SURROUND key disappears "EQ CHECK" on the display. To exit this mode, perform the "Cold Reset" (reset clearing memory) as described below. SECTION 2 TEST MODE AGING MODE 1. CD aging mode To execute the CD aging, set the three discs to the CD tray and set the function to CD. REPEAT, ENTER/NEXT and LOOP buttons simultaneously. The CD aging mode starts and the disc calendar starts blinking. 2. Tape aging mode To execute the tape aging, set the two tapes to the tape A and B drives. Set the function to TAPE. Press the REPEAT, ENTER/ NEXT and LOOP buttons simultaneously. Press the A forward key to start the tape aging mode. "AGING" appears on the display. CD SERVICE MODE Turn on the main power. Press the REPEAT, ENTER/NEXT and KARAOKE PON/MPX buttons simultaneously. VACS toggles between ON and OFF. VACS LEVEL DISPLAY Turn on the main power. Press the EDIT, ENTER/NEXT and KARAOKE PON/MPX buttons simultaneously. VACS level appears on the display. CD SHIP MODE Turn on the main power. Press the PLAY MODE and POWER buttons simultaneously. The main power is turned off and LOCK appears on the display. TUNER STEP CHANGE Turn on the main power. Set the function to TUNER. Select MW band from the present tuning. Turn off the main power. Press the ENTER/NEXT and POWER buttons simultaneously. The main power is turned on and the changed step appears on the display. MD/VIDEO 1 FUNCTION CHANGE Press the FUNCTION and POWER buttons simultaneously while the main power is off. When the function is set to VIDEO 1, the function is changed to MD and MD appears on the display. When the function is set to MD, the function is changed to VIDEO 1 and VIDEO 1 appears on the display. COLD RESET (Reset which clears memory.) Press the REPEAT, ENTER/NEXT and DISPLAY buttons simultaneously at any time. The system is reset while clearing memory. HOT RESET (Reset which does not clear memory.) Press the REPEAT, ENTER/NEXT and TIMER SELECT buttons simultaneously at any time. The system is reset without clearing memory. STR microprocessor version number HCD microprocessor version number VCD microprocessor version number (VCD model only) Model name Destination 3-1. CIRCUIT BOARDS LOCATION SECTION 3 DIAGRAMS — 6 — SEC BOARD PANEL BOARD AVIN BOARD JOG BOARD VOLUME BOARD MIC ECHO BOARD AMP BOARD MAIN BOA ENCAPSULATED COMPONE DUMMY BOARD PRI BOARD

3-7. IC PIN FUNCTION • IC501 TMP87CM75F-6608 (DISPLAY CONTROL) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 to 42 43 to 46 47 48 49 50 51 to 64 65 to 98 99 100 I/O — — O I O O O O I I — O I I O I — I I I I I I I I — I/O I/O — — — O O O O O O O — I I I — — — O O O — Description Not used POWER SUPPLY FOR VFT DRIVER Transfer clock output serial data Serial data input Serial data output Chip enable output Latch output to IC504 H : D542, D543 ON Stereo signal input Tuned signal input Power supply (Ground) Oscillator connection terminal (8MHz) Oscillator connection terminal (8MHz) Reset signal input terminal Oscillator connection terminal (32.768kHz) Oscillator connection terminal (32.768kHz) Not used (Ground) AC Power supply off RDS DATA input (European model only) RDS clock input (European model only) SIRCS signal input JOG dial encoder input Volum encoder input Volum encoder input JOG dial encoder input Not used 12C clock I/O 12C data I/O Not used Power supply (5V) Power supply (Ground) Latch output to IC105 Latch output to IC2002 Mute output to transistor L : Mute ON DBFB level control output L : DBFB HIGH Latch output to IC6003 H : Key con ON L : SP relay ON Not used Key data input (A/D converter) Spectrum analyzer signal input Input for model select Power supply for analog (Ground) Power supply (+5V) Power supply (Ground) Grid output to FL501 Segment output to FL501 H : MUTE L : Signal Receiving Not used Pin Name NC VG COM CLK ST DATA IN COM DATA ST CE LED LAT POWER ON/OFF STEREO TUNED Vss X OUT X IN RESET XT OUT XT IN GND BACK UP RDS DATA RDS CLK SIRCS IN JOG IN B VOL IN B VOL IN A JOG IN A AUB IN 12C CLK 12C DATA AUB OUT VDD Vss EQ LAT VR LAT TA MUTE VIDEO MD KEY CON LAT KEY CON ON/OFF POWER ON/OFF P LOG RELAY KEY IN 0 to 2 SPEANA 0 to 3 SUFFIX VASS VAREF VDD FL–1G to 14G FL–P1 to P34 ST MUTE NC

3-8. IC BLOCK DIAGRAMS 1 2 3 4 5 6 7 8 OVER LOAD DET F/F OFFSET DET LATCH/ AUTORESET VCC ON MUTE AC OFF DET VCC IC850 µPC1237HA IC105 M62427FP-A IC6003 M65847FP IC6002 M65850P 1 2 3 4 5 6 7 8 ADCONT DA1CONT KEY DOWN KEY UP DAIINTIN ADINTOUT ADINTIN LPF1 REF REF REF REF HPF LPF2 MIX CLKO/KEY0 SDATA/KEY1 SCK/KEY2 STROBE/KEY3 KEY4 KEY5 REF GND VCC MODE2 MODE1 DAIINTOUT LPF1IN LPF1OUT HPFIN HPFOUT LPF2IN LPF2OUT MIXIN MIXOUT DA2CONT 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 + – LOGIC D/A RESET RAM A/D CLOCK GENERATOR REF + – + – + – OSCILLATOR 1/2 VCC AUTO RESET LPF1 MAIN CONTROL A/D 20KBIT SRAM LPF2 D/A 1 2 3 4 5 6 7 8 9 10 14 13 12 11 CLOCK RESET MO MI D1 DO0 DO1 VCC CLOCK REF OP2IN OP2OUT LPF2IN LPF2OUT LPF1IN LPF1OUT OP1OUT OP1IN CC1 CC2 GND + – + – + – + – + – + – + – SBAND GRAPHIC EQUALIZER SBAND GRAPHIC EQUALIZER U-CON INTER FACE + – + – + – + – + – + – + – + – 1 2 3 4 5 6 7 8 9 10 20 19 18 17 16 15 14 13 12 11 21 22 23 24 64 63 62 61 60 59 58 57 56 55 45 46 47 48 49 50 51 52 53 54 44 43 42 41 25 26 27 28 29 30 31 32 33 34 40 39 38 37 36 35 80 79 78 77 76 75 74 73 72 71 65 66 67 68 69 70 KEY OUT1 NC3 REC 1A REC 1B REC 1C NC4 F1 F1 F1 O1 F1 IN1 F2 F1 F2 O1 F2 IN1 F3 F1 F3 O1 F3 IN1 F4 F1 F4 O1 F4 IN1 F5 F1 F OUT1 VOL OUT1 VOL IN1 BBIN1 BB11 BB12 BBIN2 VOL OUT2 VOL IN2 F OUT2 F5 F2 F4 IN2 F4 O2 F4 F2 F3 IN2 F3 O2 F3 F2 F2 IN2 F2 O2 F2 F2 F1 IN2 F1 O2 F1 F2 NC6 REC 2C REC 2B REC 2A NC7 KEY OUT2 BB22 BUF IN1 BUF OUT1 NC5 AVDD DGND LATCH DATA CLOCK DVDD PORT C PORT B PORT A BUFOUT1 BUFIN1 BB21 KEY IN1 DELAY OUT DELAY IN NC2 IN 1B NC1 IN 1A AGND AVSS IN 2A NC9 IN 2B NC8 BPF IN BPF OUT KEY IN2

have some differences from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. • Abbreviation MY : Malaysia SP : Singapore HK : Hong Kong IA : Indonesian CH : Chinese The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. — 25 — Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 4-1. MAIN SECTION 1 3-363-099-11 SCREW (CASE 3 TP2) * 2 4-991-364-11 CASE * 3 1-666-059-11 SEC BOARD * 4 1-666-065-11 PRI BOARD * 5 1-666-066-11 AMP BOARD 6 1-233-546-21 ENCAPSULATED COMPONENT * 7 1-666-067-11 DUMMY BOARD * 8 4-991-361-01 PANEL (VCD), BACK (MY,SP) * 8 4-991-361-11 PANEL (VCD), BACK (CH) * 8 4-991-361-21 PANEL (VCD), BACK (HK) * 8 4-991-361-31 PANEL (VCD), BACK (IA) * 9 A-4403-202-A MAIN BOARD, COMPLETE 10 4-970-381-11 FOOT (REAR) * 11 3-703-244-00 BUSHING (2104), CORD (IA) 11 3-703-571-11 BUSHING (S) (4516), CORD (MY,SP,HK,CH) !12 1-777-071-21 CORD, POWER (MY,SP,HK) !12 1-782-315-11 CORD, POWER (IA) !12 1-782-464-21 CORD, POWER (CH) !13 1-569-007-11 ADAPTOR, CONVERSION 2P (IA) !13 1-569-008-21 ADAPTOR, CONVERSION 2P (MY,SP) !13 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (HK) !T901 1-431-365-11 TRANSFORMER, POWER 2 1 1 3 4 11 5 7 10 9 8 #3 #5 not supplied not supplied not supplied #3 #4 #2 T901 #2 #1 #3 #3 #3 #3 6 12 IC901 13 MY, SP, HK MODEL MY, SP MODEL 13 HK MODEL 12 13 IA MODEL 12 CH MODEL

4-2. PANEL SECTION Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 51 4-991-318-01 KNOB (VOL) 52 4-991-326-01 KNOB (CENTER) 53 4-991-317-01 KNOB (JOG) 54 4-977-358-11 CUSHION 55 X-4948-895-1 PANEL ASSY, FRONT 56 4-962-708-11 EMBLEM (4-A), SONY 57 X-4948-612-1 DISPLAY ASSY, BUTTON * 58 4-932-810-11 CUSHION (FL) * 59 4-986-870-01 HOLDER, FL TUBE * 60 1-606-060-11 AVIN BOARD * 61 1-666-062-11 JOG BOARD 62 X-4948-611-1 BUTTON (E/N) ASSY 63 4-984-085-01 SPRING (ENTER), COMPRESSION * 64 A-4403-204-A PANEL BOARD, COMPLETE 65 4-951-620-01 SCREW (2.6X8), +BVTP * 66 A-4403-207-A MIC ECHO BOARD, COMPLET 67 4-991-327-01 KNOB (CONTROL) FL501 1-517-618-11 INDICATOR TUBE, FLUORESCENT 58 59 61 62 60 56 53 51 55 63 65 65 65 65 65 66 64 FL501 54 57 52 67

please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks — 27 — • COILS uH: µH • SEMICONDUCTORS In each case, u: µ, for example: uA...: µA... , uPA... , µPA... , uPB... , µPB... , uPC... , µPC... , uPD..., µPD... • Abbreviation MY : Malaysia SP : Singapore HK : Hong Kong IA : Indonesian CH : Chinese • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • CAPACITORS: uF: µF • RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable SECTION 5 ELECTRICAL PARTS LIST * 1-666-066-11 AMP BOARD ********* < CAPACITOR > C809 1-104-664-11 ELECT 47uF 20% 25V C810 1-104-664-11 ELECT 47uF 20% 25V C811 1-126-933-11 ELECT 100uF 20% 16V C812 1-104-664-11 ELECT 47uF 20% 25V C813 1-104-664-11 ELECT 47uF 20% 25V C816 1-104-664-11 ELECT 47uF 20% 25V C817 1-126-933-11 ELECT 100uF 20% 10V C818 1-104-664-11 ELECT 47uF 20% 25V C819 1-104-664-11 ELECT 47uF 20% 25V C901 1-126-961-11 ELECT 2.2uF 20% 50V C902 1-162-294-31 CERAMIC 0.001uF 10% 50V C903 1-162-282-31 CERAMIC 100PF 10% 50V C904 1-126-967-11 ELECT 47uF 20% 50V C905 1-126-967-11 ELECT 47uF 20% 50V C906 1-136-495-11 FILM 0.068uF 5% 50V C907 1-136-495-11 FILM 0.068uF 5% 50V C932 1-128-552-51 ELECT 47uF 20% 63V C933 1-128-581-11 ELECT 4.7uF 20% 63V C934 1-128-552-51 ELECT 47uF 20% 63V C937 1-126-965-11 ELECT 22uF 20% 50V C938 1-126-934-11 ELECT 220uF 20% 16V C940 1-128-581-11 ELECT 4.7uF 20% 63V C950 1-162-306-11 CERAMIC 0.01uF 20% 16V C951 1-126-963-11 ELECT 4.7uF 20% 50V C952 1-162-294-31 CERAMIC 0.001uF 10% 50V C953 1-162-282-31 CERAMIC 100PF 10% 50V C954 1-126-967-11 ELECT 47uF 20% 50V C955 1-126-967-11 ELECT 47uF 20% 50V C956 1-136-495-11 FILM 0.068uF 5% 50V C957 1-136-495-11 FILM 0.068uF 5% 50V < DIODE > D805 8-719-933-50 DIODE HZS7C2L D806 8-719-001-57 DIODE UZL-11H3-TP D807 8-719-000-81 DIODE UZL-7L3 D808 8-719-933-50 DIODE HZS7C2L D903 8-719-987-63 DIODE 1N4148M D953 8-719-987-63 DIODE 1N4148M < IC > IC901 8-749-921-04 IC STK-4211MK-2 < TRANSISTOR > Q802 8-729-209-15 TRANSISTOR 2SD2012 Q803 8-729-209-15 TRANSISTOR 2SD2012 Q804 8-729-209-15 TRANSISTOR 2SD2012 Q805 8-729-141-83 TRANSISTOR 2SB1094-LK Q901 8-729-900-36 TRANSISTOR DTC124ES Q902 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Q952 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA Q8004 8-729-620-05 TRANSISTOR 2SC2603-EF < RESISTOR > R805 1-249-428-11 CARBON 8.2K 5% 1/4W F R807 1-247-843-11 CARBON 3.3K 5% 1/4W R809 1-249-428-11 CARBON 8.2K 5% 1/4W F R814 1-249-421-11 CARBON 2.2K 5% 1/4W F R815 1-249-421-11 CARBON 2.2K 5% 1/4W F R901 1-249-417-11 CARBON 1K 5% 1/4W F R902 1-249-437-11 CARBON 47K 5% 1/4W R903 1-249-412-11 CARBON 390 5% 1/4W F R904 1-249-437-11 CARBON 47K 5% 1/4W R906 1-249-429-11 CARBON 10K 5% 1/4W R907 1-249-429-11 CARBON 10K 5% 1/4W R908 1-249-429-11 CARBON 10K 5% 1/4W R909 1-249-429-11 CARBON 10K 5% 1/4W R910 1-249-397-11 CARBON 22 5% 1/4W F R911 1-249-397-11 CARBON 22 5% 1/4W F R913 1-249-417-11 CARBON 1K 5% 1/4W F R914 1-249-431-11 CARBON 15K 5% 1/4W R915 1-249-441-11 CARBON 100K 5% 1/4W !R920 1-217-156-00 WIREWOUND 0.22 10% 5W F !R932 1-212-881-11 FUSIBLE 100 5% 1/4W F R933 1-249-421-11 CARBON 2.2K 5% 1/4W F R934 1-249-421-11 CARBON 2.2K 5% 1/4W F R935 1-249-421-11 CARBON 2.2K 5% 1/4W F R936 1-249-421-11 CARBON 2.2K 5% 1/4W F R937 1-249-437-11 CARBON 47K 5% 1/4W R938 1-249-441-11 CARBON 100K 5% 1/4W R939 1-249-433-11 CARBON 22K 5% 1/4W R940 1-249-433-11 CARBON 22K 5% 1/4W R941 1-249-429-11 CARBON 10K 5% 1/4W R942 1-249-413-11 CARBON 470 5% 1/4W F !R943 1-212-881-11 FUSIBLE 100 5% 1/4W F R945 1-249-417-11 CARBON 1K 5% 1/4W F R951 1-249-417-11 CARBON 1K 5% 1/4W F R952 1-249-437-11 CARBON 47K 5% 1/4W R953 1-249-412-11 CARBON 390 5% 1/4W F AMP

R954 1-249-437-11 CARBON 47K 5% 1/4W R956 1-249-429-11 CARBON 10K 5% 1/4W R957 1-249-429-11 CARBON 10K 5% 1/4W R958 1-249-429-11 CARBON 10K 5% 1/4W R959 1-249-429-11 CARBON 10K 5% 1/4W R960 1-249-397-11 CARBON 22 5% 1/4W F R961 1-249-397-11 CARBON 22 5% 1/4W F R963 1-249-417-11 CARBON 1K 5% 1/4W F R964 1-249-431-11 CARBON 15K 5% 1/4W R965 1-249-441-11 CARBON 100K 5% 1/4W !R970 1-217-156-00 WIREWOUND 0.22 10% 5W F !R974 1-212-849-00 FUSIBLE 4.7 5% 1/4W F ************************************************************ * 1-666-060-11 AVIN BOARD ********** < CAPACITOR > C6301 1-162-286-31 CERAMIC 220PF 10% 50V C6302 1-162-286-31 CERAMIC 220PF 10% 50V C6303 1-162-306-11 CERAMIC 0.01uF 20% 16V < CONNECTOR > CN6301 1-564-524-11 PLUG, CONNECTOR 9P < DIODE > D6300 8-719-987-63 DIODE 1N4148M < JACK > J6301 1-779-583-11 JACK, PIN 3P (AV INPUT) < RESISTOR > R6301 1-249-417-11 CARBON 1K 5% 1/4W F R6302 1-249-417-11 CARBON 1K 5% 1/4W F R6303 1-249-441-11 CARBON 100K 5% 1/4W R6304 1-249-441-11 CARBON 100K 5% 1/4W < RELAY > RY6300 1-515-622-11 RELAY ************************************************************ * 1-666-062-11 JOG BOARD ********** < DIODE > D512 8-719-046-44 DIODE SEL5221S (ENTER/NEXT) D513 8-719-046-44 DIODE SEL5221S (→) D514 8-719-046-44 DIODE SEL5221S (←) < RESISTOR > R537 1-249-407-11 CARBON 150 5% 1/4W F R538 1-249-401-11 CARBON 47 5% 1/4W F R541 1-249-419-11 CARBON 1.5K 5% 1/4W F R644 1-249-429-11 CARBON 10K 5% 1/4W R645 1-249-429-11 CARBON 10K 5% 1/4W < SWITCH > S534 1-762-751-11 SWITCH, TACTILE (ENTER/NEXT) S536 1-762-874-11 SWITCH, JOG (MULTI JOG STATION) ************************************************************ * A-4403-202-A MAIN BOARD,COMPLETE ******************** < CAPACITOR > C101 1-136-167-00 FILM 0.15uF 5% 50V C102 1-130-471-00 MYLAR 0.001uF 5% 50V C103 1-136-169-00 FILM 0.22uF 5% 50V C104 1-136-169-00 FILM 0.22uF 5% 50V C105 1-136-495-11 FILM 0.068uF 5% 50V C106 1-136-495-11 FILM 0.068uF 5% 50V C107 1-137-440-11 FILM 0.018uF 5% 50V C108 1-137-440-11 FILM 0.018uF 5% 50V C109 1-137-437-11 FILM 0.0056uF 5% 50V C110 1-130-479-00 MYLAR 0.0047uF 5% 50V C111 1-130-479-00 MYLAR 0.0047uF 5% 50V C112 1-126-964-11 ELECT 10uF 20% 50V C113 1-126-963-11 ELECT 4.7uF 20% 50V C114 1-136-166-00 FILM 0.12uF 5% 50V C115 1-136-166-00 FILM 0.12uF 5% 50V C116 1-126-961-11 ELECT 2.2uF 20% 50V C117 1-162-306-11 CERAMIC 0.01uF 20% 16V C118 1-126-964-11 ELECT 10uF 20% 50V C120 1-126-959-11 ELECT 0.47uF 20% 50V C123 1-126-963-11 ELECT 4.7uF 20% 50V C129 1-162-294-31 CERAMIC 0.001uF 10% 50V C130 1-164-159-11 CERAMIC 0.1uF 50V C140 1-162-306-11 CERAMIC 0.01uF 20% 16V C153 1-136-169-00 FILM 0.22uF 5% 50V C154 1-136-169-00 FILM 0.22uF 5% 50V C155 1-136-495-11 FILM 0.068uF 5% 50V C156 1-136-495-11 FILM 0.068uF 5% 50V C157 1-137-440-11 FILM 0.018uF 5% 50V C158 1-137-440-11 FILM 0.018uF 5% 50V C159 1-137-437-11 FILM 0.0056uF 5% 50V C160 1-130-479-00 MYLAR 0.0047uF 5% 50V C161 1-130-479-00 MYLAR 0.0047uF 5% 50V C162 1-126-964-11 ELECT 10uF 20% 50V C163 1-126-963-11 ELECT 4.7uF 20% 50V C164 1-136-166-00 FILM 0.12uF 5% 50V C165 1-136-166-00 FILM 0.12uF 5% 50V C166 1-126-961-11 ELECT 2.2uF 20% 50V C177 1-162-306-11 CERAMIC 0.01uF 20% 16V C181 1-162-215-31 CERAMIC 47PF 5% 50V C182 1-126-960-11 ELECT 1uF 20% 50V C183 1-126-961-11 ELECT 2.2uF 20% 50V C188 1-126-964-11 ELECT 10uF 20% 50V C703 1-126-963-11 ELECT 4.7uF 20% 50V C731 1-126-964-11 ELECT 10uF 20% 50V C732 1-126-964-11 ELECT 10uF 20% 50V C753 1-126-963-11 ELECT 4.7uF 20% 50V C801 1-136-165-00 FILM 0.1uF 5% 50V C802 1-136-165-00 FILM 0.1uF 5% 50V C803 1-104-482-11 ELECT 4700uF 20% 63V C804 1-104-482-11 ELECT 4700uF 20% 63V AMP AVIN JOG MAIN The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.

C807 1-126-964-11 ELECT 10uF 20% 50V C808 1-126-948-11 ELECT 100uF 20% 35V C831 1-126-942-61 ELECT 1000uF 20% 25V C832 1-126-942-61 ELECT 1000uF 20% 25V C835 1-136-165-00 FILM 0.1uF 5% 50V C836 1-136-165-00 FILM 0.1uF 5% 50V C852 1-126-923-11 ELECT 220uF 20% 10V C853 1-126-933-11 ELECT 100uF 20% 10V C858 1-104-664-11 ELECT 47uF 20% 25V C859 1-126-961-11 ELECT 2.2uF 20% 50V C861 1-164-159-11 CERAMIC 0.1uF 50V C6100 1-162-284-31 CERAMIC 150PF 10% 50V C6101 1-126-964-11 ELECT 10uF 20% 50V C6102 1-162-290-31 CERAMIC 470PF 10% 50V C6103 1-162-291-31 CERAMIC 560PF 10% 50V C6104 1-249-429-11 CARBON 10K 5% 1/4W C6106 1-162-294-31 CERAMIC 0.001uF 10% 50V C6107 1-164-159-11 CERAMIC 0.1uF 50V C6108 1-164-159-11 CERAMIC 0.1uF 50V C6109 1-136-495-11 FILM 0.068uF 5% 50V C6110 1-136-495-11 FILM 0.068uF 5% 50V C6111 1-136-495-11 FILM 0.068uF 5% 50V C6112 1-162-286-31 CERAMIC 220PF 10% 50V C6113 1-162-286-31 CERAMIC 220PF 10% 50V C6114 1-162-294-31 CERAMIC 0.001uF 10% 50V C6115 1-164-159-11 CERAMIC 0.1uF 50V C6116 1-126-967-11 ELECT 47uF 20% 10V C6117 1-164-159-11 CERAMIC 0.1uF 50V C6118 1-124-584-00 ELECT 100uF 20% 10V C6119 1-126-964-11 ELECT 10uF 20% 50V C6120 1-126-964-11 ELECT 10uF 20% 50V C6121 1-126-964-11 ELECT 10uF 20% 50V C6123 1-162-306-11 CERAMIC 0.01uF 20% 16V C6125 1-249-429-11 CARBON 10K 5% 1/4W < CONNECTOR > CN103 1-774-289-11 PIN, CONNECTOR (PC BOARD) 15P CN105 1-774-336-11 SOCKET, CONNECTOR(PC BOARD) 14P CN106 1-774-336-11 SOCKET, CONNECTOR(PC BOARD) 14P * CN6002 1-568-937-11 PIN, CONNECTOR 10P * CNP701 1-764-017-21 HOUSING,CONNECTOR(PC BOARD) 17P < DIODE > D101 8-719-987-63 DIODE 1N4148M D102 8-719-987-63 DIODE 1N4148M D702 8-719-024-99 DIODE 11ES2-NTA2B D801 8-719-302-38 DIODE RBV-602-01 D804 8-719-934-22 DIODE HZS30-2L D809 8-719-987-63 DIODE 1N4148M D810 8-719-987-63 DIODE 1N4148M D821 8-719-987-63 DIODE 1N4148M D824 8-719-024-99 DIODE 11ES2-NTA2B D831 8-719-024-99 DIODE 11ES2-NTA2B D832 8-719-024-99 DIODE 11ES2-NTA2B D833 8-719-024-99 DIODE 11ES2-NTA2B D834 8-719-024-99 DIODE 11ES2-NTA2B D840 8-719-987-63 DIODE 1N4148M D841 8-719-987-63 DIODE 1N4148M D844 8-719-024-99 DIODE 11ES2-NTA2B D852 8-719-987-63 DIODE 1N4148M D1021 8-719-987-63 DIODE 1N4148M < TERMINAL > * E801 1-537-738-21 TERMINAL, EARTH < IC > IC101 8-759-634-50 IC M5218AL IC105 8-759-460-02 IC M62427FP-A IC701 8-759-000-47 IC MC14051BCP IC751 8-759-000-47 IC MC14051BCP IC850 8-759-111-68 IC uPC1237HA IC6003 8-759-370-84 IC M65847FP IC6004 8-759-140-53 IC uPD4053BC < JACK > J701 1-770-614-11 JACK, PIN 4P (MD/VIDEO 1) J901 1-779-379-11 JACK, PIN 2P (SUPER WOOFER/MONITOR) < COIL > L6100 1-410-521-11 INDUCTOR 100uH < TRANSISTOR > Q111 8-729-119-78 TRANSISTOR 2SC403SP-51 Q112 8-729-119-78 TRANSISTOR 2SC403SP-51 Q161 8-729-119-78 TRANSISTOR 2SC403SP-51 Q162 8-729-119-78 TRANSISTOR 2SC403SP-51 Q190 8-729-900-63 TRANSISTOR DTA124ES Q191 8-729-141-26 TRANSISTOR 2SC3622A-LK Q192 8-729-141-26 TRANSISTOR 2SC3622A-LK Q801 8-729-141-83 TRANSISTOR 2SB1094-LK Q810 8-729-900-36 TRANSISTOR DTC124ES Q856 8-729-900-36 TRANSISTOR DTC124ES Q857 8-729-900-63 TRANSISTOR DTA124ES Q2100 8-729-141-26 TRANSISTOR 2SC3622A-LK Q6001 8-729-119-78 TRANSISTOR 2SC403SP-51 Q6002 8-729-900-80 TRANSISTOR DTC114ES < RESISTOR > R101 1-249-429-11 CARBON 10K 5% 1/4W R102 1-249-429-11 CARBON 10K 5% 1/4W R103 1-249-429-11 CARBON 10K 5% 1/4W R104 1-249-429-11 CARBON 10K 5% 1/4W R105 1-249-429-11 CARBON 10K 5% 1/4W R108 1-247-897-11 CARBON 560K 5% 1/4W R109 1-249-419-11 CARBON 1.5K 5% 1/4W F R110 1-249-433-11 CARBON 22K 5% 1/4W R111 1-249-441-11 CARBON 100K 5% 1/4W R112 1-249-421-11 CARBON 2.2K 5% 1/4W F R113 1-249-441-11 CARBON 100K 5% 1/4W R115 1-249-439-11 CARBON 68K 5% 1/4W R116 1-249-437-11 CARBON 47K 5% 1/4W R117 1-247-903-00 CARBON 1M 5% 1/4W R118 1-249-417-11 CARBON 1K 5% 1/4W F R119 1-249-433-11 CARBON 22K 5% 1/4W R120 1-249-437-11 CARBON 47K 5% 1/4W R122 1-247-903-00 CARBON 1M 5% 1/4W R123 1-249-431-11 CARBON 15K 5% 1/4W R124 1-249-437-11 CARBON 47K 5% 1/4W MAIN

R125 1-247-807-31 CARBON 100 5% 1/4W R126 1-249-429-11 CARBON 10K 5% 1/4W R129 1-247-887-00 CARBON 220K 5% 1/4W R137 1-247-807-31 CARBON 100 5% 1/4W R138 1-247-807-31 CARBON 100 5% 1/4W R139 1-247-807-31 CARBON 100 5% 1/4W R140 1-247-807-31 CARBON 100 5% 1/4W R141 1-247-807-31 CARBON 100 5% 1/4W R142 1-247-807-31 CARBON 100 5% 1/4W R143 1-247-807-31 CARBON 100 5% 1/4W R144 1-247-807-31 CARBON 100 5% 1/4W R145 1-247-807-31 CARBON 100 5% 1/4W R146 1-247-807-31 CARBON 100 5% 1/4W R147 1-247-807-31 CARBON 100 5% 1/4W R151 1-249-429-11 CARBON 10K 5% 1/4W R152 1-249-429-11 CARBON 10K 5% 1/4W R153 1-249-429-11 CARBON 10K 5% 1/4W R154 1-249-429-11 CARBON 10K 5% 1/4W R155 1-249-429-11 CARBON 10K 5% 1/4W R156 1-249-429-11 CARBON 10K 5% 1/4W R158 1-247-897-11 CARBON 560K 5% 1/4W R159 1-249-419-11 CARBON 1.5K 5% 1/4W F R160 1-249-433-11 CARBON 22K 5% 1/4W R161 1-249-441-11 CARBON 100K 5% 1/4W R162 1-249-421-11 CARBON 2.2K 5% 1/4W F R163 1-249-441-11 CARBON 100K 5% 1/4W R165 1-249-439-11 CARBON 68K 5% 1/4W R167 1-249-441-11 CARBON 100K 5% 1/4W R172 1-247-903-00 CARBON 1M 5% 1/4W R173 1-249-431-11 CARBON 15K 5% 1/4W R174 1-249-437-11 CARBON 47K 5% 1/4W R176 1-249-429-11 CARBON 10K 5% 1/4W R177 1-249-437-11 CARBON 47K 5% 1/4W R178 1-249-433-11 CARBON 22K 5% 1/4W R181 1-247-895-00 CARBON 470K 5% 1/4W R182 1-247-895-00 CARBON 470K 5% 1/4W R183 1-249-435-11 CARBON 33K 5% 1/4W R184 1-249-429-11 CARBON 10K 5% 1/4W R185 1-247-843-11 CARBON 3.3K 5% 1/4W R186 1-249-425-11 CARBON 4.7K 5% 1/4W F R187 1-249-441-11 CARBON 100K 5% 1/4W R188 1-249-417-11 CARBON 1K 5% 1/4W F R190 1-249-441-11 CARBON 100K 5% 1/4W R192 1-249-425-11 CARBON 4.7K 5% 1/4W F R195 1-249-425-11 CARBON 4.7K 5% 1/4W F R196 1-247-807-31 CARBON 100 5% 1/4W R702 1-249-425-11 CARBON 4.7K 5% 1/4W F R703 1-249-425-11 CARBON 4.7K 5% 1/4W F R704 1-249-417-11 CARBON 1K 5% 1/4W F R705 1-249-441-11 CARBON 100K 5% 1/4W R707 1-249-441-11 CARBON 100K 5% 1/4W R708 1-249-417-11 CARBON 1K 5% 1/4W F R710 1-249-417-11 CARBON 1K 5% 1/4W F R752 1-249-425-11 CARBON 4.7K 5% 1/4W F R753 1-249-425-11 CARBON 4.7K 5% 1/4W F R754 1-249-417-11 CARBON 1K 5% 1/4W F R755 1-249-441-11 CARBON 100K 5% 1/4W R757 1-249-441-11 CARBON 100K 5% 1/4W R758 1-249-417-11 CARBON 1K 5% 1/4W F R759 1-249-417-11 CARBON 1K 5% 1/4W F R760 1-249-417-11 CARBON 1K 5% 1/4W F R762 1-249-417-11 CARBON 1K 5% 1/4W F !R801 1-212-982-00 FUSIBLE 100 5% 1/2W F R804 1-249-429-11 CARBON 10K 5% 1/4W R818 1-249-427-11 CARBON 6.8K 5% 1/4W F R819 1-249-427-11 CARBON 6.8K 5% 1/4W F R840 1-249-429-11 CARBON 10K 5% 1/4W R851 1-249-431-11 CARBON 15K 5% 1/4W R853 1-249-397-11 CARBON 22 5% 1/4W F R854 1-249-441-11 CARBON 100K 5% 1/4W R856 1-249-429-11 CARBON 10K 5% 1/4W R857 1-249-435-11 CARBON 33K 5% 1/4W R858 1-249-437-11 CARBON 47K 5% 1/4W R859 1-249-439-11 CARBON 68K 5% 1/4W !R870 1-215-892-11 METAL OXIDE 1K 5% 2W F R944 1-249-417-11 CARBON 1K 5% 1/4W F R1002 1-249-429-11 CARBON 10K 5% 1/4W R1020 1-249-425-11 CARBON 4.7K 5% 1/4W F R1021 1-249-417-11 CARBON 1K 5% 1/4W F R6100 1-249-429-11 CARBON 10K 5% 1/4W R6101 1-247-807-31 CARBON 100 5% 1/4W R6102 1-249-417-11 CARBON 1K 5% 1/4W F R6103 1-249-433-11 CARBON 22K 5% 1/4W R6105 1-249-431-11 CARBON 15K 5% 1/4W R6106 1-249-424-11 CARBON 3.9K 5% 1/4W F R6109 1-249-425-11 CARBON 4.7K 5% 1/4W F R6111 1-247-903-00 CARBON 1M 5% 1/4W R6112 1-249-425-11 CARBON 4.7K 5% 1/4W F R6113 1-247-807-31 CARBON 100 5% 1/4W R6115 1-249-441-11 CARBON 100K 5% 1/4W R6116 1-249-433-11 CARBON 22K 5% 1/4W R6117 1-249-433-11 CARBON 22K 5% 1/4W R6118 1-249-441-11 CARBON 100K 5% 1/4W R6119 1-249-441-11 CARBON 100K 5% 1/4W R6120 1-249-441-11 CARBON 100K 5% 1/4W R6124 1-249-417-11 CARBON 1K 5% 1/4W F R6125 1-249-429-11 CARBON 10M 5% 1/4W < RELAY > RY801 1-515-920-11 RELAY (24V) < TERMINAL > TB901 1-537-240-31 TERMINAL BOARD (CHECKER PIN) ************************************************************ The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. MAIN

* A-4403-207-A MIC ECHO BOARD, COMPLETE ************************* < CAPACITOR > C6001 1-162-306-11 CERAMIC 0.01uF 20% 16V C6002 1-162-306-11 CERAMIC 0.01uF 20% 16V C6003 1-124-257-00 ELECT 2.2uF 20% 50V C6004 1-124-257-00 ELECT 2.2uF 20% 50V C6005 1-162-215-31 CERAMIC 47PF 5% 50V C6006 1-162-290-31 CERAMIC 470PF 10% 50V C6008 1-126-160-11 ELECT 1uF 20% 50V C6009 1-162-294-31 CERAMIC 0.001uF 10% 50V C6010 1-136-495-11 FILM 0.068uF 5% 50V C6011 1-104-664-11 ELECT 47uF 20% 25V C6012 1-126-160-11 ELECT 1uF 20% 50V C6013 1-126-160-11 ELECT 1uF 20% 50V C6014 1-104-664-11 ELECT 47uF 20% 25V C6015 1-124-250-11 ELECT 0.15uF 20% 50V C6016 1-162-305-11 CERAMIC 0.0068uF 30% 16V C6017 1-136-495-11 FILM 0.068uF 5% 50V C6018 1-162-305-11 CERAMIC 0.0068uF 30% 16V C6019 1-162-294-31 CERAMIC 0.001uF 10% 50V C6020 1-126-160-11 ELECT 1uF 20% 50V C6021 1-162-306-11 CERAMIC 0.01uF 20% 16V C6023 1-162-215-31 CERAMIC 47PF 5% 50V C6024 1-162-282-31 CERAMIC 100PF 10% 50V C6025 1-124-257-00 ELECT 2.2uF 20% 50V C6026 1-124-261-00 ELECT 10uF 20% 50V C6027 1-124-261-00 ELECT 10uF 20% 50V C6028 1-162-306-11 CERAMIC 0.01uF 20% 16V C6030 1-124-465-00 ELECT 0.47uF 20% 50V C6032 1-162-306-11 CERAMIC 0.01uF 20% 16V C6033 1-162-306-11 CERAMIC 0.01uF 20% 16V < DIODE > D6001 8-719-987-63 DIODE 1N4148M D6002 8-719-987-63 DIODE 1N4148M D6003 8-719-987-63 DIODE 1N4148M < TERMINAL > * G6001 1-537-738-21 TERMINAL, EARTH < IC > IC6001 8-759-634-51 IC M5218AP IC6002 8-759-450-96 IC M65850P < JACK > J6001 1-770-226-11 JACK (LARGE TYPE) (MIX MIC1) J6002 1-750-733-11 JACK (LARGE TYPE) (MIX MIC2) J6003 1-770-226-11 JACK (LARGE TYPE) (PHONES) < RESISTOR > R6001 1-249-429-11 CARBON 10K 5% 1/4W R6002 1-249-429-11 CARBON 10K 5% 1/4W R6003 1-249-417-11 CARBON 1K 5% 1/4W F R6004 1-249-417-11 CARBON 1K 5% 1/4W F R6005 1-249-417-11 CARBON 1K 5% 1/4W F R6006 1-249-425-11 CARBON 4.7K 5% 1/4W F R6007 1-249-433-11 CARBON 22K 5% 1/4W R6008 1-249-433-11 CARBON 22K 5% 1/4W R6009 1-249-433-11 CARBON 22K 5% 1/4W R6010 1-247-881-00 CARBON 120K 5% 1/4W R6011 1-249-437-11 CARBON 47K 5% 1/4W R6012 1-249-433-11 CARBON 22K 5% 1/4W R6013 1-249-433-11 CARBON 22K 5% 1/4W R6014 1-249-433-11 CARBON 22K 5% 1/4W R6015 1-249-417-11 CARBON 1K 5% 1/4W F R6016 1-247-843-11 CARBON 3.3K 5% 1/4W R6017 1-249-417-11 CARBON 1K 5% 1/4W F R6018 1-247-881-00 CARBON 120K 5% 1/4W R6019 1-247-807-31 CARBON 100 5% 1/4W R6030 1-247-895-00 CARBON 470K 5% 1/4W R6201 1-249-419-11 CARBON 1.5K 5% 1/4W F R6202 1-249-418-11 CARBON 1.2K 5% 1/4W F R6251 1-249-419-11 CARBON 1.5K 5% 1/4W F R6252 1-249-418-11 CARBON 1.2K 5% 1/4W F < VARIABLE RESISTOR > RV6001 1-225-511-11 RES,VAR,CARBON 50K/50K (MIC LEVEL/ECHO VOL) ************************************************************ * A-4403-204-A PANEL BOARD, COMPLETE ********************** VOLUME BOARD ************** * 4-932-810-11 CUSHION (FL) * 4-986-870-01 HOLDER, FL TUBE < CAPACITOR > C501 1-164-159-11 CERAMIC 0.1uF 50V C502 1-164-159-11 CERAMIC 0.1uF 50V C503 1-162-203-31 CERAMIC 15PF 5% 50V C504 1-162-205-31 CERAMIC 18PF 5% 50V C505 1-126-964-11 ELECT 10uF 20% 50V C506 1-137-399-11 FILM 0.1uF 5% 50V C507 1-124-248-00 ELECT 22uF 20% 35V C508 1-162-306-11 CERAMIC 0.01uF 20% 16V C509 1-126-964-11 ELECT 10uF 20% 50V C510 1-162-306-11 CERAMIC 0.01uF 20% 16V C511 1-124-584-00 ELECT 100uF 20% 10V C512 1-126-964-11 ELECT 10uF 20% 50V C514 1-126-964-11 ELECT 10uF 20% 50V C515 1-162-306-11 CERAMIC 0.01uF 20% 16V C516 1-126-964-11 ELECT 10uF 20% 50V MIC ECHO PANEL VOLUME

C517 1-137-374-11 FILM 0.047uF 5% 50V C518 1-162-306-11 CERAMIC 0.01uF 20% 16V C519 1-124-464-11 ELECT 0.22uF 20% 50V C520 1-137-371-11 FILM 0.015uF 5% 50V C521 1-124-463-00 ELECT 0.1uF 20% 50V C522 1-164-159-11 CERAMIC 0.1uF 50V C523 1-162-302-11 CERAMIC 0.0022uF 30% 16V C524 1-162-301-11 CERAMIC 0.0015uF 30% 16V C525 1-162-288-31 CERAMIC 330PF 10% 50V C526 1-164-159-11 CERAMIC 0.1uF 50V C527 1-164-159-11 CERAMIC 0.1uF 50V C528 1-104-905-11 CAPACITOR 0.22F 5.5V C544 1-162-306-11 CERAMIC 0.01uF 20% 16V C545 1-162-306-11 CERAMIC 0.01uF 20% 16V C546 1-162-306-11 CERAMIC 0.01uF 20% 16V C549 1-162-284-31 CERAMIC 150PF 10% 50V C550 1-162-286-31 CERAMIC 220PF 10% 50V < CONNECTOR > CN501 1-774-342-11 PLUG, CONNECTOR (PC BOARD) 14P CN502 1-774-342-11 PLUG, CONNECTOR (PC BOARD) 14P < DIODE > D505 8-719-032-86 DIODE SEL5420E (KEY CONTROL n) D506 8-719-046-36 DIODE SEL5921A-TH15 (KEY CONTROL ˜) D511 8-719-987-63 DIODE 1N4148M D518 8-719-046-39 DIODE SEL5821A-TH15 (VCD) D519 8-719-046-39 DIODE SEL5821A-TH15 (PBC) D520 8-719-046-39 DIODE SEL5821A-TH15 (AUTO PBC) D521 8-719-046-80 DIODE SML19416W-TP4 (MOVIE) D522 8-719-046-39 DIODE SEL5821A-TH15 (DNR) D523 8-719-046-80 DIODE SML19416W-TP4 (P FILE) D524 8-719-046-80 DIODE SML19416W-TP4 (P FILE) D525 8-719-046-80 DIODE SML19416W-TP4 (GAME) D526 8-719-046-80 DIODE SML19416W-TP4 (GAME) D527 8-719-046-80 DIODE SML19416W-TP4 (MOVIE) D528 8-719-046-80 DIODE SML19416W-TP4 (MUSIC) D529 8-719-046-39 DIODE SEL5821A-TH15 (CD) D530 8-719-046-39 DIODE SEL5821A-TH15 (TUNER) D531 8-719-046-39 DIODE SEL5821A-TH15 (TIMER) D532 8-719-046-80 DIODE SML19416W-TP4 (MUSIC) D533 8-719-046-39 DIODE SEL5821A-TH15 (EFFECT) D534 8-719-046-44 DIODE SEL5221S (EFFECT ON/OFF) D536 8-719-032-86 DIODE SEL5420E (TUNER BAND) D537 8-719-032-86 DIODE SEL5420E (TUNER BAND) D538 8-719-046-44 DIODE SEL5221S (GROOVE) D539 8-719-046-44 DIODE SEL5221S (GROOVE) D540 8-719-046-36 DIODE SEL5921A-TH15 (DBFB) D541 8-719-046-36 DIODE SEL5921A-TH15 (DBFB) D542 8-719-064-63 DIODE SELU5823A-TP15 D543 8-719-064-63 DIODE SELU5823A-TP15 D575 8-719-987-63 DIODE 1N4148M D576 8-719-987-63 DIODE 1N4148M D579 8-719-024-99 DIODE 11ES2-NTA2B D580 8-719-987-63 DIODE 1N4148M D581 8-719-987-63 DIODE 1N4148M D582 8-719-014-73 DIODE UZP-5.6BC-TP D583 8-719-024-99 DIODE 11ES2-NTA2B D585 8-719-987-63 DIODE 1N4148M D586 8-719-987-63 DIODE 1N4148M D587 8-719-987-63 DIODE 1N4148M D588 8-719-987-63 DIODE 1N4148M D589 8-719-987-63 DIODE 1N4148M < FILTER > FL501 1-517-618-11 INDICATOR TUBE, FLUORESCENT < IC > IC501 8-759-483-31 IC TMP87CM75F-6623 IC502 8-759-332-18 IC GP1U27XB IC503 8-759-165-82 IC PST600E-T IC504 8-759-372-64 IC M66313FP-200C < COIL > L502 1-408-074-00 INDUCTOR 56uH < TRANSISTOR > Q501 8-729-119-78 TRANSISTOR 2SC403SP-51 Q502 8-729-422-57 TRANSISTOR UN4111 Q503 8-729-119-78 TRANSISTOR 2SC403SP-51 Q504 8-729-422-57 TRANSISTOR UN4111 Q505 8-729-422-57 TRANSISTOR UN4111 Q506 8-729-422-57 TRANSISTOR UN4111 Q507 8-729-422-57 TRANSISTOR UN4111 Q508 8-729-422-57 TRANSISTOR UN4111 Q509 8-729-422-57 TRANSISTOR UN4111 Q510 8-729-422-57 TRANSISTOR UN4111 < RESISTOR > R501 1-249-407-11 CARBON 150 5% 1/4W F R502 1-249-409-11 CARBON 220 5% 1/4W F R503 1-249-411-11 CARBON 330 5% 1/4W R504 1-249-413-11 CARBON 470 5% 1/4W F R505 1-249-415-11 CARBON 680 5% 1/4W F R506 1-249-417-11 CARBON 1K 5% 1/4W F R507 1-249-407-11 CARBON 150 5% 1/4W F R508 1-249-411-11 CARBON 330 5% 1/4W R511 1-249-407-11 CARBON 150 5% 1/4W F R512 1-249-409-11 CARBON 220 5% 1/4W F R513 1-249-411-11 CARBON 330 5% 1/4W R514 1-249-413-11 CARBON 470 5% 1/4W F R515 1-249-415-11 CARBON 680 5% 1/4W F R516 1-249-417-11 CARBON 1K 5% 1/4W F R517 1-249-419-11 CARBON 1.5K 5% 1/4W F R518 1-249-421-11 CARBON 2.2K 5% 1/4W F R519 1-247-843-11 CARBON 3.3K 5% 1/4W R520 1-249-427-11 CARBON 6.8K 5% 1/4W F R521 1-249-431-11 CARBON 15K 5% 1/4W R522 1-249-437-11 CARBON 47K 5% 1/4W R523 1-249-413-11 CARBON 470 5% 1/4W F R524 1-249-415-11 CARBON 680 5% 1/4W F R525 1-249-417-11 CARBON 1K 5% 1/4W F R526 1-249-419-11 CARBON 1.5K 5% 1/4W F R527 1-249-421-11 CARBON 2.2K 5% 1/4W F R528 1-247-843-11 CARBON 3.3K 5% 1/4W R529 1-249-427-11 CARBON 6.8K 5% 1/4W F R530 1-249-431-11 CARBON 15K 5% 1/4W R531 1-249-437-11 CARBON 47K 5% 1/4W R532 1-249-409-11 CARBON 220 5% 1/4W F PANEL VOLUME

R534 1-249-407-11 CARBON 150 5% 1/4W F R535 1-249-407-11 CARBON 150 5% 1/4W F R542 1-249-407-11 CARBON 150 5% 1/4W F R543 1-249-407-11 CARBON 150 5% 1/4W F R544 1-249-407-11 CARBON 150 5% 1/4W F R545 1-249-407-11 CARBON 150 5% 1/4W F R550 1-249-407-11 CARBON 150 5% 1/4W F R551 1-249-407-11 CARBON 150 5% 1/4W F R552 1-249-407-11 CARBON 150 5% 1/4W F R553 1-249-407-11 CARBON 150 5% 1/4W F R554 1-249-413-11 CARBON 470 5% 1/4W F R555 1-249-401-11 CARBON 47 5% 1/4W F R556 1-247-807-31 CARBON 100 5% 1/4W R557 1-249-399-11 CARBON 33 5% 1/4W F R559 1-247-807-31 CARBON 100 5% 1/4W R560 1-247-807-31 CARBON 100 5% 1/4W R561 1-247-807-31 CARBON 100 5% 1/4W R563 1-247-807-31 CARBON 100 5% 1/4W R564 1-247-807-31 CARBON 100 5% 1/4W R565 1-247-807-31 CARBON 100 5% 1/4W R566 1-247-807-31 CARBON 100 5% 1/4W R567 1-247-807-31 CARBON 100 5% 1/4W R568 1-247-807-31 CARBON 100 5% 1/4W R569 1-247-807-31 CARBON 100 5% 1/4W R570 1-247-807-31 CARBON 100 5% 1/4W R571 1-247-807-31 CARBON 100 5% 1/4W R572 1-247-807-31 CARBON 100 5% 1/4W R573 1-247-807-31 CARBON 100 5% 1/4W R574 1-247-807-31 CARBON 100 5% 1/4W R575 1-247-807-31 CARBON 100 5% 1/4W R576 1-247-807-31 CARBON 100 5% 1/4W R577 1-247-807-31 CARBON 100 5% 1/4W R580 1-249-427-11 CARBON 6.8K 5% 1/4W F R581 1-249-427-11 CARBON 6.8K 5% 1/4W F R583 1-249-403-11 CARBON 68 5% 1/4W F R584 1-249-403-11 CARBON 68 5% 1/4W F R585 1-249-403-11 CARBON 68 5% 1/4W F R586 1-249-403-11 CARBON 68 5% 1/4W F R587 1-249-403-11 CARBON 68 5% 1/4W F R588 1-249-403-11 CARBON 68 5% 1/4W F R589 1-249-403-11 CARBON 68 5% 1/4W F R590 1-249-403-11 CARBON 68 5% 1/4W F R601 1-249-433-11 CARBON 22K 5% 1/4W R602 1-249-437-11 CARBON 47K 5% 1/4W R603 1-249-437-11 CARBON 47K 5% 1/4W R604 1-249-429-11 CARBON 10K 5% 1/4W R605 1-249-441-11 CARBON 100K 5% 1/4W R606 1-249-425-11 CARBON 4.7K 5% 1/4W F R610 1-249-429-11 CARBON 10K 5% 1/4W R611 1-249-429-11 CARBON 10K 5% 1/4W R613 1-249-429-11 CARBON 10K 5% 1/4W R614 1-249-409-11 CARBON 220 5% 1/4W F R615 1-249-409-11 CARBON 220 5% 1/4W F R616 1-247-843-11 CARBON 3.3K 5% 1/4W R617 1-247-843-11 CARBON 3.3K 5% 1/4W R618 1-247-843-11 CARBON 3.3K 5% 1/4W R619 1-249-429-11 CARBON 10K 5% 1/4W R620 1-249-429-11 CARBON 10K 5% 1/4W R621 1-249-429-11 CARBON 10K 5% 1/4W R622 1-249-429-11 CARBON 10K 5% 1/4W R623 1-249-429-11 CARBON 10K 5% 1/4W R624 1-249-429-11 CARBON 10K 5% 1/4W R630 1-249-435-11 CARBON 33K 5% 1/4W R631 1-249-435-11 CARBON 33K 5% 1/4W R632 1-249-437-11 CARBON 47K 5% 1/4W R633 1-247-903-00 CARBON 1M 5% 1/4W R634 1-249-437-11 CARBON 47K 5% 1/4W R635 1-247-903-00 CARBON 1M 5% 1/4W R636 1-249-435-11 CARBON 33K 5% 1/4W R637 1-249-429-11 CARBON 10K 5% 1/4W R638 1-249-437-11 CARBON 47K 5% 1/4W R639 1-249-437-11 CARBON 47K 5% 1/4W R640 1-247-903-00 CARBON 1M 5% 1/4W R641 1-247-903-00 CARBON 1M 5% 1/4W R642 1-249-431-11 CARBON 15K 5% 1/4W R643 1-249-427-11 CARBON 6.8K 5% 1/4W F R662 1-247-903-00 CARBON 1M 5% 1/4W R663 1-247-903-00 CARBON 1M 5% 1/4W R664 1-247-903-00 CARBON 1M 5% 1/4W R665 1-247-903-00 CARBON 1M 5% 1/4W R666 1-249-417-11 CARBON 1K 5% 1/4W F < SWITCH > S501 1-762-751-11 SWITCH, TACTILE (MOVIE) S502 1-762-751-11 SWITCH, TACTILE (MUSIC) S503 1-762-751-11 SWITCH, TACTILE (EFFECT ON/OFF) S504 1-762-751-11 SWITCH, TACTILE (LOW FREQ) S505 1-762-751-11 SWITCH, TACTILE (MEMORY) S506 1-762-751-11 SWITCH, TACTILE (TUNING MODE) S507 1-762-751-11 SWITCH, TACTILE (FLASH) S508 1-762-751-11 SWITCH, TACTILE (POWER) S512 1-762-751-11 SWITCH, TACTILE (GAME) S513 1-762-751-11 SWITCH, TACTILE (P FILE) S514 1-762-751-11 SWITCH, TACTILE (MEMO) S515 1-762-751-11 SWITCH, TACTILE (HIGH FREQ) S516 1-762-751-11 SWITCH, TACTILE (REPEAT) S517 1-762-751-11 SWITCH, TACTILE (1/ALL DISCS) S518 1-762-751-11 SWITCH, TACTILE (PLAY MODE) S519 1-762-751-11 SWITCH, TACTILE (EDIT) S520 1-762-751-11 SWITCH, TACTILE (DBFB) S521 1-762-751-11 SWITCH, TACTILE (GROOVE) S522 1-762-751-11 SWITCH, TACTILE (FUNCTION) S523 1-762-751-11 SWITCH, TACTILE (MONO/ST) S524 1-762-751-11 SWITCH, TACTILE (TUNER BAND) S525 1-762-751-11 SWITCH, TACTILE (TIMER SELECT) S526 1-762-751-11 SWITCH, TACTILE (CLOCK TIMER SET) S529 1-762-751-11 SWITCH, TACTILE (KEY CONTROL n) S530 1-762-751-11 SWITCH, TACTILE (KEY CONTROL ˜) S531 1-762-751-11 SWITCH, TACTILE (KARAOKE PON/MPX) S532 1-762-751-11 SWITCH, TACTILE (SURROUND) S533 1-762-751-11 SWITCH, TACTILE (LOOP) S535 1-467-869-11 ENCODER, ROTARY (VOLUME) S537 1-762-751-11 SWITCH, TACTILE (WAVE) S538 1-762-751-11 SWITCH, TACTILE (DISPLAY/DEMO) < VIBRATOR > X501 1-579-125-11 VIBRATOR, CERAMIC 5MHz X502 1-567-098-41 VIBRATOR, CRYSTAL 32KHz ************************************************************ PANEL VOLUME

* 1-666-065-11 PRI BOARD ********** 1-533-293-11 FUSE HOLDER < CONNECTOR > CN851 1-564-321-00 PIN, CONNECTOR 2P < FUSE > !F851 1-532-465-51 FUSE,TIME LAG 3.15A 250V !F852 1-532-506-51 FUSE,TIME LAG 6.3A 250V < SWITCH > !VS851 1-572-675-11 SWITCH, POWER VOLTAGE CHANGE ************************************************************ * 1-666-059-11 SEC BOARD ********** 1-533-293-11 FUSE HOLDER < CONNECTOR > * CN852 1-564-527-11 PLUG, CONNECTOR 12P < FUSE > !F857 1-532-506-51 FUSE,TIME LAG 6.3A 250V !F858 1-532-506-51 FUSE,TIME LAG 6.3A 250V < RESISTOR > !R853 1-219-123-11 FUSIBLE 0.47 5% 1/4W F !R854 1-219-123-11 FUSIBLE 0.47 5% 1/4W F !R855 1-219-121-11 FUSIBLE 0.22 5% 1/4W F !R856 1-219-121-11 FUSIBLE 0.22 5% 1/4W F ************************************************************ MISCELLANEOUS ************** 6 1-233-546-21 ENCAPSULATED COMPONENT 7 1-666-067-11 DUMMY BOARD !12 1-777-071-21 CORD, POWER (MY,SP,HK) !12 1-782-315-11 CORD, POWER (IA) !12 1-782-464-21 CORD, POWER (CH) !13 1-569-007-11 ADAPTOR, CONVERSION 2P (IA) !13 1-569-008-21 ADAPTOR, CONVERSION 2P (MY,SP) !13 1-770-019-11 ADAPTOR, CONVERSION PLUG 3P (HK) !F851 1-532-465-51 FUSE,TIME LAG 3.15A 250V !F852 1-532-506-51 FUSE,TIME LAG 6.3A 250V !F857 1-532-506-51 FUSE,TIME LAG 6.3A 250V !F858 1-532-506-51 FUSE,TIME LAG 6.3A 250V !T901 1-431-365-11 TRANSFORMER, POWER ************************************************************ ************** HARDWARE LIST ************** #1 7-685-872-09 SCREW +BVTT 3X8 (S) #2 7-685-881-09 SCREW +BVTT 4X8 (S) #3 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S #4 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S #5 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3 PRI SEC The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. STR-V5500 Sony Corporation Home A&V Products Company 9-920-961-11 97H16086-1 Printed in Japan © 1997.8 Published by General Engineering Dept. (Shibaura)