Spirit E-210 Owner's Manual

BEFORE OPERATING YOUR GAS GRILL  DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open fl ames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fi re department. Leaking gas may cause a fi re or explosion which can cause serious bodily injury or death, or damage to property.  WARNING 1. Do not store or use gasoline or other fl ammable liquids or vapors in the vicinity of this or any other appliance . 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.  WARNING: Follow all leak-check procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. NOTICE TO INSTALLER: These instructions must be left with the owner and the owner should keep them for future use. THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONLY. 89527 7/14/06 NG US ENGLISH GAS GRILL #00000 #89527  WARNING: Do not try to light this appliance without reading the “Lighting Instructions” section of this manual. Natural Gas Grill Owner’s Guide Natural Gas Grill Owner’s Guide E -210/310 SP -210/310

death, or in a fi re or an explosion causing damage to property.  WARNINGS  Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.  Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual.  After a period of storage, and/or nonuse, the Weber® gas barbecue should be checked for gas leaks and burner obstructions before use. See instructions in this manual for correct procedures.  Do not operate the Weber® gas barbecue if there is a gas leak present.  Do not use a fl ame to check for gas leaks.  Combustible materials should never be within 24 inches of the back or sides of your Weber® gas barbecue.  Do not put a barbecue cover or anything fl ammable on, or in the storage area under the barbecue.  Your Weber® gas barbecue should never be used by children. Accessible parts of the barbecue may be very hot. Keep young children away while it is in use.  You should exercise reasonable care when operating your Weber® gas barbecue. It will be hot during cooking or cleaning and should never be left unattended, or moved while in operation.  Should the burners go out while in operation, turn all gas valves off. Open the lid and wait fi ve minutes before attempting to relight, using the lighting instructions.  Do not use charcoal or lava rock in your Weber® gas barbecue.  Never lean over open grill or place hands or fi ngers on the front edge of the cooking box.  Should a grease fi re occur, turn off all burners and leave lid closed until fi re is out.  Do not enlarge valve orifi ces or burner ports when cleaning the valves or burners.  The Weber® gas barbecue should be thoroughly cleaned on a regular basis.  Liquid propane gas is not natural gas. The conversion or attempted use of natural gas in a liquid propane unit or liquid propane gas in a natural gas unit is dangerous and will void your warranty.  Do not attempt to disconnect any gas fi tting while your barbecue is in operation.  Use heat-resistant barbecue mitts or gloves when operating barbecue.  Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.  Combustion byproducts produced when using this product contain chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm.  Do not use this barbecue unless all parts are in place. The unit must be properly assembled according to the instructions outlined in the “Assembly Instructions”. LIQUID PROPANE GAS UNITS ONLY:  Use the regulator that is supplied with your Weber® gas barbecue.  Do not attempt to disconnect the gas regulator or any gas fi tting while your barbecue is in operation.  A dented or rusty liquid propane cylinder may be hazardous and should be checked by your liquid propane supplier. Do not use a liquid propane cylinder with a damaged valve.  Although your liquid propane cylinder may appear to be empty, gas may still be present, and the cylinder should be transported and stored accordingly.  If you see, smell or hear the hiss of escaping gas from the liquid propane cylinder: 1. Move away from liquid propane cylinder. 2. Do not attempt to correct the problem yourself. 3. Call your fi re department. DANGERS AND WARNINGS

gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 25 years Casting Paint, 2 years no burn-off Porcelain Lid Section, 10 years Stainless Steel Lid Section, 25 years no rust through or burn through Stainless Steel Burners Tubes, 10 years no rust through Porcelain Enameled Cast Iron Cooking Grates, 5 years no rust through or burn through Porcelain Enameled Flavorizer® Bars, 3 years no rust through or burn through Stainless Steel Cooking Grates, 7 years no rust through or burn through Stainless Steel Flavorizer® Bars, 7 years no rust through or burn through All Remaining Parts, 2 years when assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE. This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are defective. Before returning any parts, contact the Customer Service Representative in your area using the contact information on our website. If Weber confi rms the defect and approves the claim, Weber will elect to replace such parts without charge. If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage prepaid. This Limited Warranty does not cover any failures or operating diffi culties due to accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or service, or failure to perform normal and routine maintenance, including but not limited to damage caused by insects within the burner tubes, as set out in this owner’s manual. Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not covered by this Limited Warranty. There are no other express warrants except as set forth herein and any applicable implied warranties of merchantability and fi tness are limited in duration to the period of coverage of this express written Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this limitation may not apply to you. Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you. Weber does not authorize any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal, return, or replacement of its equipment; and no such representations are binding on Weber. This Warranty applies only to products sold at retail. WEBER-STEPHEN PRODUCTS CO. Customer Service Center 1890 Roselle Road, Suite 308 Schaumburg, IL 60195 USA For replacement parts call: 1-800-446-1071 www.weber.com® WARRANTY

46 56 12 3XX1001 - Spirit® Gas Grill NG 071406 5 6 7 8 9 10 11 13 16 17 23 24 25 27 28 30 31 41 42 43 44 45 47 48 50 51 52 53 57 59 63 18 19 15 14 65 1 2 3 4 34 35 37 38 36 39 55 58 66 21 22 29 32 49 62 64 67 68 26 54 33 41 48 40 58 20 61 60 EXPLODED VIEW - DIAGRAMA DE DESPIECE - VISION ÉCLATÉE

Axe d’articulation 2. Left Endcap Capacete izquierdo Capuchon d’extrémité gauche 3. Shroud Cubierta Protection 4. Handle Asa Poignée 5. Warm-Up™ Basket Canasta Warm-Up™ Panier Warm-Up™ 6. Warming Rack Parrilla para calentar Grille de réchauffage 7. Cooking Grates Parrilla para asar Grilles de cuisson 8. Flavorizer® Bars Barras Flavorizer® Barres Flavorizer® 9. Cooking Box Cámara para asar Cuve 10. 1/4-20 Keps Nut Tuerca de enclavamiento (Tuerca de enclavamiento de 1/4” x 20) Écrou Keps (1/4 x 20) 11. Slide-Out Bottom Tray Bandeja del fondo Plateau inférieur amovible 12. Work Surface Superfi cie de trabajo Plan de travail 13. Catch Pan Holder Soporte de la bandeja para recoger el exceso de grasa Support de lèchefrite 14. Left Rear Trim Assembly Arm Brazo de la estructura de ajuste trasera izquierda Bras de la garniture arrière gauche 15. 1/4 - 14 x 5/8 inch Bolt Pernos de 5/8” (Pernos de 1/4” x 14 x 5/8”) Boulons de 5/8 po (1/4 x 14 x 5/8 po) 16. Left Trim Piece Pieza de ajuste izquierda Garniture gauche 17. Left Front Trim Assembly Arm Left Front Trim Assembly Arm Bras de la garniture avant gauche 18. 1/4 - 20 x 2 1/4 inch Bolt Pernos de 2 1/4” (Pernos de 1/4” x 20 x 2 1/4”) Boulons de 2 1/4 po (1/4 x 20 x 2 1/4 po) 19. Fuel Gauge Hardware Elementos de Medidor del gas Boulonnerie de Jauge de combustible 20. Condiment Basket Canastilla de condimentos Panier à condiments 21. Panel Hardware Elementos de Panel Boulonnerie de Panneau 22. Left Frame Panel Tablero del bastidor izquierdo Panneau du cadre gauche 23. 1/4 - 20 x 1 inch Bolt Pernos de 1/4” (Pernos de 1/4” x 20 x 1/4”) Boulons de 1/4 po (1/4 x 20 x 1/4 po) 24. Nylon Washer Arandela de nilón Rondelle en nylon 25. Caster Frame Bastidor para los rodillos Châssis des roulettes 26. Door Bushing Buje de puerta Bagne de porte 27. Caster Rodillo Roulette 28. Bottom Shelf Estante inferior Plateau inférieur 29. Left Door Puerta izquierda Porte gauche 30. Wheel Ruedas Roues 31. Hubcap Tapacubos Couvre-moyeux 32. Handle Asa Poignée 33. Right Door Puerta derecha Porte droite 34. Hair Pin Cotter Pasador de horquilla Goupille bêta 35. Right Endcap Capacete derecho Capuchon d’extrémité droite 36. Thermometer Bezel Assembly Ensamblaje biselado para el termómetro Montage de la collerette de fi xation du thermomètre 37. Thermometer Assembly Termómetro Thermomètre 38. Handle Hardware Elementos de Asa Boulonnerie de Poignée 39. Control Panel Knobs Perilla de control Manette de réglage 40. Control Panel Knob Perilla de control Manette de réglage 41. Control Panel Panel de control Panneau de commande 42. Control Panel Hardware Tornillería del panel de control (Destornillador Phillips y arandelas Visserie du panneau de commande (vis à empreinte cruciforme et rondelles) 43. Crossover® Ignition Button Botón del encendedor® Bouton d’allumeur® 44. Crossover® Tube Tubo Crossover® Tube Crossover® 45. Front/Rear Burner Quemador frontal/trasero Brûleur avant / arrière 46. Center Burner Quemador Central Brûleur central 47. Manifold Hardware Tornillería del distribuidor Boulonnerie de collecteur 48. Manifold, Hose and Regulator Distribuidor, manguera y regulador Collecteur, tuyau et détendeur 49. Rear Panel Panel trasero Panneau arrière 50. Catch Pan Bandeja para recoger el exceso de grasa Lèchefrite 51. Disposable Drip Pan Bandejas recogegotas Barquette jetable 52. Igniter Encendedor Allumeur 53. Top Frame Assembly Estructura de bastidor superior Longeron de cadre de châssis sommet 54. Front Panel Hardware Herrajes del tablero frontal Matériel du panneau avant 55. Fuel Gauge Medidor del gas Jauge de combustible 56. Control Panel Hardware Tornillería del panel de control (Destornillador Phillips y arandelas Visserie du panneau de commande (vis à empreinte cruciforme et rondelles) 57. Right Trim Piece Pieza de ajuste derecha Garniture droite 58. Condiment Basket Canastilla de condimentos Panier à condiments 59. Front Panel Quemador delantero Panneau avant 60. Hose Manga Tuyau 61. Right Frame Panel Hardware Elementos de Tablero del bastidor derecho Boulonnerie de Panneau du cadre droit 62. Right Frame Panel Tablero del bastidor derecho Panneau du cadre droit 63. Wheel Frame Bastidor para las ruedas Châssis des roues 64. Cylinder Glides Soportes de la bombona Glissières de bouteille 65. 1/4 - 20 x 1 3/4 inch Bolt Pernos de 1 3/4” (Pernos de 1/4” x 20 x 1 3/4”) Boulons de 1 3/4 po (1/4 x 20 x 1 3/4 po) 66. Door Glides Deslizadores de la puerta Glissières de la porte 67. Hinge Rods Varilla articulada Tige d’articulation 68. Matchlight Holder Sujetador de Fósforo Support d’allumage par allumette EXPLODED LIST - LISTA DEL DIAGRAMA - LISTE DE LA VISION ÉCLATÉE