STA-RITE Signature 2000 Owner's Manual

OWNER’s MANUAL Signature 2000 High Pressure Booster Pump 60 Hz. 1/2 through 3 HP © 2012 Pentair, Inc. All Rights Reserved. S327 (11/01/12) 293 WRIGHT STREET, DELAVAN, WI 53115 WWW.STA-RITE.COM PH: 888-782-7483 ...

STA-RITE Signature 2000 from defects in material and workmanship for the Warranty Period shown below. Product Warranty Period Water Systems Products — jet pumps, small centrifugal pumps, submersible pumps and related accessories ...

SAFETY INSTRUCTIONS! This is the safety alert symbol. When you see this symbol on your pump or in this manual, look for one of the following signal words and be alert to the potential for personal injury: warns about hazards that will cause seri- ous personal injury, death or major property damage if ignored. warns about hazards that can caus ...

STA-RITE Signature 2000 7A figure 11 – Exploded view. HP20H-01 HP20H3-01 HP20E-02 HP20f-02 HP20G-02 HP20HT-02 Key HP20E3-02 HP20f3-02 HP20G3-02 HP20H3T-02 No. Description Qty. 1 HP 1-1/2 HP 2 HP 3 HP 1 Motor - 115/230 Volt, 1 Phase 1 J218-601PKG J218-883APKG J218-628APKG – 1 Motor - 230 Volt, 1 Phase 1 – – A100GSL AE100HLL 1 ...

STA-RITE Signature 2000 line should be short and have as few elbows as possible. Size the inlet according to the chart below: An inlet strainer will prevent suspended debris from clogging pump. The internal running surfaces of the pump and seals require water lubrication for good, consistent operation. allowing pump to run dry ...

6A figure 14 – Exploded view. HPS30E-01 HPS30f-01 HPS30G-01 HPS30H-01 HPS30E3-0 HPS30f3-01 HPS30G3-01 HPS30H3-01 HPS30ET-01 HPS30fT-01 HPS30GT-01 HPS30HT-01 Key HPS30E3T-01 HPS30f3T-01 HPS30G3T-01 HPS30H3T-01 No. Description Qty. 1HP 1-1/2 HP 2 HP 3 HP 1 Motor - 115/230 Volt, 1 Phase 1 J218-601PKG J218-883APKG J21 ...

STA-RITE Signature 2000 6A figure 10 – Exploded view. HPS7C-01 HPS7D-01 HPS7E-01 HPS7C3-01 HPS7D3-01 HPS7E3-01 HPS10C-01 HPS10D-01 HPS10E-01 HPS10f-01 HPS10G-01 Key HPS10C3-01 HPS10D3-01 HPS10E3-01 HPS10f3-01 HPS10G3-01 No. Description Qty. 1/2 HP 3/4 HP 1HP 1-1/2 HP 2 HP 1 Motor - 115/230 Volt, 1 Phase 1 J218-590PKG J218-596PKG J218-601 ...

STA-RITE Signature 2000 7A figure 9 – Exploded view. Hose 6’-3/4” w/Female Ends (150 PSI Rating) PKG 83 Hose 25’-3/4” w/Male & Female Ends (150 PSI Rating) PKG 84 Adapter 3/4” NPT x 3/4” Hose PKG 85 Nozzle - High Pressure PKG 86 Suction Vacuum Relief Valve PKG 96 THE fOllOWING aCCESSOrIES May BE OrDErED fOr HIG ...

STA-RITE Signature 2000 (Refer to Figures 8 and 9) This procedure is best completed with the pump held in a vertical position, motor down. First complete “Disassembly” instructions 1 through 5 under “Impeller Stack Changeout.” (See Figure 8). 6. Remove 4 capscrews holding pump body to motor. Pump handle will come off with top capscrews. 7. Unscre ...

STA-RITE Signature 2000 cause death. Disconnect power before servicing. Tools required: 1. 7/16” open end wrench (2 required). 2. Flat blade screwdriver with insulated handle. 3. Work bench with vise recommended. 4. Pliers or similar tool. 5. Pipe wrench. Impeller Stack Changeout (See Figure 8) Remove pump from ...