MCi J4500 Operator's Manual

1--Introduction 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2--Daily Inspections 5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3--Switches, Warning Lights and Gauges 9 . . . . . . . . . . . . . . . . . . . . . 4--Steering Column and Floor-Mounted Controls 25 . . . . . . . . . . . . . . 5--Operating Features 29 . . . . . . . . . . . . . . . . . . . . . ...

Typical illustrations may be used, therefore minor illustration differences may exist when compared to actual parts or other publications COACH APPLICABILITY This manual supports the MCI J4500 Coach. TO THE DRIVER This manual has been prepared to provide you with the information you need to operate the MCI J4500 Series Coach. The specifications and information throughout this manual are subject to change without notice. Report ...

The nameplate and the certification plate both contain the seventeen-character vehicle identification number (VIN).The numbers correspond to the items in the following list. 1. The first three characters identify the manufacturing company: 1M8 = MCI Inc. (U.S.) 2MG = MCI Ltd. (Canada) 2. The fourth character identifies the coach model: 3 = J4500 Intercity 3. The fifth character identifies the series: J = J-Se ...

1. Instrument Panel • System Gauges • LH Tell-tale Cluster • RH Tell-tale Cluster • Driver’s Vents 2. Lower, LH Console • Cup Holder • Headlight Switch • Mirror Controls • Pushbutton Shift Selector • Switches • Wheelchair Master Switch ( Optional ) • 12 Volt Power Source • Anti-Slip Pad • Emergency Park Brake Release • Front Service Compartment Door Release 3. LH Switch Panel • Driver� ...

The following checks are in addition to the Federal Motor Carrier Safety Administration requirements, not instead of them. EXTERIOR INSPECTION 1. Ensure that all windows, mirrors and lights are clean and unobstructed. 2. Ensure that all side windows are closed. A protrusion of 1/4” ( 6mm ) or more indicates that a window in not properly latched. 3. Check that the coach exterior is clear of debris, and that all service do ...

not instead of them. OPERATIONAL CHECKLIST 1. While the engine is running, look for oil or coolant leaks and listen for air leaks. 2. While the engine is running, check the alternator lights on the remote control box in the engine compartment. The lights should be OFF. Be very careful when the engine is running and the engine door is open. If i ...

Driver's Seat Belt Adjustment Using the restraint system can lessen the severity of injury in an accident or sudden maneuver. While seated straight and well back into the seat, adjust the belt as necessary. To unfasten the belt, push the release button. If a belt jams, you may be able to release it by working the belt in and out until the belt rewinds far enough to unlock. If the belt remains jammed or other restraint system ...

Before the Pre-Trip Inspection function is enabled, these functions must be met: • Position the Master Power switch to the “ON” position, • Select “NEUTRAL” on the transmission Shift Pad selector, • Set the Park Brake, • Position the Reading Light test switch to the “ON” position. • Apply and hold a service brake application of 60 psi, Only after these conditions are met, t ...

Figure 4. Instrument Panel Instrument Panel Components 1. Gauges 2. LH Tell-tale Cluster 3. RH Tell-tale Cluster 4. LH Switch Panel 5. RH Switch Panel 6. Vent 5 4 1 3 2 6 6 ...

INSTRUMENT PANEL/GAUGES Speedometer The speedometer, which features an alphanumeric message display, reads the forward speed of the coach in miles per hour or kilometers per hour. The speedometer features a MODE and TRIP button allow the driver to select, set/reset displays and scroll through active system warning messages, when the coach is at a complete stop. The MODE button is utilized to select the mode o ...

1. Front Air PSI tell-tale The low air warning tell-tale illuminates when the air pressure drops below the pre-determined level. In the event of a low air warning, stop the coach and determine the cause of air loss before proceeding. 2. Rear Air PSI tell-tale The low air warning tell-tale illuminates when the air pressure drops below the pre-determined level. In the event of a low air warning, st ...

Fuel - This gauge reads the fuel level in the tank. Diesel Exhaust Fluid ( DEF ) - The DEF gauge reads the fluid level in the tank. Engine Tachometer - The engine tachometer reads engine revolutions per minute. Figure 10. Volt and Trans Temp Gauges Voltmeter - The voltmeter reads the condition of the 24-volt electrical system. The gauge is calibrated in volts. The needle should be from 27 to 29 volts. If ...

or warning. Tell-tales are located in RH and LH clusters, in the instrument cluster. Some tell-tales are accompanied by a buzzer or bell. At system start-up, tell-tales light briefly to show that the LEDs work. LH TELL-TALE CLUSTER Figure 12. LH Tell-tale Cluster Left Turn Indicator (Green) Wait to Start (Ye ...

tale Lamp. Tell-tale indicates a failure of an emission system component. Blank Water in Fuel (Yellow) - Tell-tale indicates water in the fuel filter. Park Brake Applied (Red) Trailer Park (Red) - Tell-tale is disabled. ABS (Yellow) - Tell-tale indicates anti-lock braking system malfunction. Electronic Stability Control / Automatic Traction Control (Yellow) - Tell-tale indicates an Electronic Stability ...

Figure 13. RH Tell-tale Cluster Driver Seat Belt (Red) - Tell-tale lights when park brake is released and the driver's seat belt is not buckled. Check Info (Yellow) - Tell-tale indicates message on alphanumeric display of speedometer. Refer to next page for further information. Low Fuel (Yellow) - Tell-tale will illuminate when fuel level is below 12 percent (approx.) left in the tank. Cruise Enabled (Green) - Tell-tale i ...

The CHECK INFO tell-tale illumination indicates that a message regarding additional tell-tale information is displayed on the alphanumeric display of speedometer. Dependant of the message displayed, a buzzer may accompany the message. Move the coach to a safe parking area to view the message displayed on the alphanumeric display of speedometer. After the message has been recorded, the operator can press the TRIP button to ...

LH SWITCH PANEL 1. Fog Lights Switch 2. Mirror Heat Switch - Press this switch to clear the mirrors of fog and frost. 3. Parcel Rack Blower Switch - The PARCEL RACK switch controls the parcel rack blowers, LOW, OFF and HIGH. 4. Auxiliary Heater Switch - When the engine is OFF, the engine can be preheated by pushing the AUXILIARY HEATER switch forward, which activates a 90 minute timer in the Proheat unit. When the ...

RH SWITCH PANEL 1. Interior Light 2. Reading Lights - Turns reading lights ON and OFF. 3. Blank Switch 4. Baggage Bay Lights - Turns the baggage bay lights ON and OFF. The baggage bay lights have a timer feature that automatically shuts OFF the lights after 30 minutes, if the switch is left in the ON position. 5. LH Baggage Lock - Locks and unlocks the LH hand baggage doors. 6. RH Baggage Lock - Locks and unlocks th ...