Dodge 2006 Sprinter Manual 

1.0 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.1 SYSTEM COVERAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.2 SIX-STEP TROUBLESHOOTING PROCEDURE . . . . . . . . . . . . . . . . . . . . . . . . . .1 2.0 ...

5.0 REQUIRED TOOLS AND EQUIPMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 6.0 GLOSSARY OF TERMS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 7.0 DIAGNOSTIC INFORMATION AND PROCEDURES . . . . . . . . . . . . . . . . . . . . . . . . . . .15 ...

FLAME SENSOR SHORTED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91 GLOW PIN OPEN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91 GLOW PIN SHORTED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

A/C COMPRESSOR CONTROL SHORTED LOW (ACTIVE). . . . . . . . . . . . . . . . . . . .132 AIR OUTLET TEMP SENSOR HIGH OR OPEN (ACTIVE) . . . . . . . . . . . . . . . . . . . . .134 AIR OUTLET TEMP SENSOR SHORTED LOW (ACTIVE) . . . . . . . . . . . . . . . . . . . . .136 ATC FUNCTION TEST COOL FAILURE . . . . . . . . . . . . . . . . . ...

VEHICLE THEFT/SECURITY DRIVER CYLINDER LOCK SWITCH CIRCUIT SHORT TO GROUND . . . . . . . . . . . .212 DRIVER CYLINDER UNLOCK SWITCH CIRCUIT SHORT TO GROUND . . . . . . . . .214 FRONT DOOR JAMB SWITCH CIRCUIT SHORT TO GROUND . . . . . . . . . . . . . . . .216 INTERNAL ERROR - SSM . . . . . . . . . . . . . . . . . . . . . . . . . ...

8.9 VEHICLE THEFT SECURITY SYSTEM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .254 8.9.1 SECURITY SYSTEM MODULE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .254 8.9.2 INTRUSION SENSORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .254 8.9.3 SWITCHES . . . . . . . . . . . . ...

FUSES (FUSE BLOCK NO. 2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .274 FUSES (FUSE BLOCK NO. 3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .276 FUSES (FUSE/RELAY BLOCK) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

10.5 POWER DOOR LOCKS/RKE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .296 10.5.1 FRONT DOORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .296 10.5.2 SLIDING AND REAR DOORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .297 10.5.3 SWITCH AND MI ...

all the specifications, instructions and graphics needed to diagnose Sprinter body system problems. The diagnostics in this manual are based on the failure condition or symptom being present at the time of diagnosis. Please follow the recommendations below when choosing your diagnostic path. 1. ...

receives power from the Fuse Block No. 1. When- ever the ignition key is turned to the run or start position, the ACM performs a system test. The ACM cannot be repaired or adjusted. The microprocessor in the ACM monitors the internal and external airbag system electrical cir- cuits to determine the system readin ...