Aerco AM Series Application Manual

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 PR1 04/08/2014 GF-146-V TAG-0075_0B 399 / 500 / 750 / 1000 Gas-Fired Boilers and Water Heaters VENTING APPLICATION GUIDE Pending Pending Natural Gas or Propane Modulating & Condensing Boilers and Water Heaters Applies to ...

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 AM1 04/08/2014 AM Series Venting Application Guide GF-146-V TAG-0075_0B DISCLAIMER The information contained in this manual is subject to change without notice from AERCO International, Inc. AERCO makes no warranty of any kind with ...

Page 3 of 20 GF-146-V TAG-0075_0B GF-146 TAG-0075_0B AM Series Venting Application Guide Table of Contents Table of Contents ..................................................................................... 3 1. CODES, SAFETY, AND VENTING S ...

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 AM1 04/08/2014 AM Series Venting Application Guide GF-146-V TAG-0075_0B 1. CODES, SAFETY, AND VENTING SYSTEMS 1.1. APPLICABLE FEDERAL CODES United States: NFPA 54/ANSI Z223.1: National Fuel Gas Code NFPA/ANSI 211: Chimneys, Fireplac ...

Page 5 of 20 GF-146-V TAG-0075_0B GF-146 TAG-0075_0B AM Series Venting Application Guide 1.2. GAS VENT CATAGORIES The AM Series is approved for a Category IV vent configuration as well as for sealed combustion installations. Make provisions for ...

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 AM1 04/08/2014 AM Series Venting Application Guide GF-146-V TAG-0075_0B 1.3.4. OPTION 4: PVC/CPVC (Use Schedule 40 or thicker, Single-Wall, Uninsulated Pipes) When using Non-Metallic (Plastic) vent systems for Canadian installations ...

Page 7 of 20 GF-146-V TAG-0075_0B GF-146 TAG-0075_0B AM Series Venting Application Guide 2. COMBUSTION AIR SYSTEM Air openings to combustion area must not be obstructed. Using Table 3, air openings may be specified so that adequate combustion a ...

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 AM1 04/08/2014 AM Series Venting Application Guide GF-146-V TAG-0075_0B o If horizontal ducts are used, each opening and duct shall have a minimum free area of 1 square inch per 2,000 BTU per hour of total input rating of all applia ...

Page 9 of 20 GF-146-V TAG-0075_0B GF-146 TAG-0075_0B AM Series Venting Application Guide Figure 3: Combustion Air Roof Termination Locations • All inlet air ducts must be sealed air tight. • When using sealed combustion, the combustion air ...

AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, New York 10913 • Phone: 800-526-0288 AM1 04/08/2014 AM Series Venting Application Guide GF-146-V TAG-0075_0B 2.2. COMBUSTION AIR PIPE SIZING The maximum length is the combined length of straight horizontal and vertical runs, and the equivalent straight length of fitti ...