Maximum Controls MAX SUPER ARM 1300 Manual 

MAX SUPER ARM 1300 Heavy Duty Residential Linear Gate Operator Overload clutch release on 2-ton impact 2 Year Warranty or 100,000 Cycles whichever comes first Max cloud app & DSP controlLer UL 2018 THE NEW STANDARD Rev. 1.3_ April 29 Timers Diagnose Users Settings GATE STATUS: OPEN, OPENING, CLOSED CLOSE OPEN LAGUNA WOODS GATE GATE RELEASE

• Two independently adjustable closing speed controls with 16 positions each • Switchable 115/230 voltage selection • Adaptive DSP motor control for advanced motion control • Real time performance analyzer and event log (OBD PORT and Black Box) • Magic Box enables low voltage wiring capabilities for remote power up to 1000 ft • On-board switch for solar mode enables 5 milliamp idle in sleep mode • Gold contact input connections and automobile grade connectors • -4F to 165F (-20C to +74C) operational range including battery backup without a heater • Shipping weight of Actuator: Super Arm 1300 (25 lbs) • Shipping weight of AC Control Box (38 lbs) • The patented brake system allows the operator to retract with extreme force. When the force exceeds 2 tons, the clutch releases upon impact, then automatically resets. Causes for clutch release include a vehicle strike while the gate is in motion. • Stainless steel output shaft - 1 1/4” • Direct gear drive (no internal chains, belts, or pulleys) • Mechanical and electrical gate release functions • Continuous duty cycle at extreme temperature range. No overheating • Intelligent ramp-up and ramp-down for smooth gate operation MAX SUPER ARM 1300 FEATURE LIST: = Unique to Max SUPER ARM 1300 100 75 Cmin 955 – Cmax 1450 min 995 – max 1490 58 116 58 115 40 30 70 380 65 180 100 37 7.3” Min = 37” ” Max = 54.75” 8ft 10ft 12ft 1300 lbs 800 lbs 600 lbs Max Weight/ Length Gate Capacity 2

• Vehicle hit protection technology protects the gate operator from collision damage caused by automobile impact, avoiding costly repairs • Built in advanced entrapment protection and alarm output • Built in gate-in-motion alarm for industrial applications • Robust lightning protection, up to 20KVolts and 10KAmps on all inputs and outputs (35 channels) including loop detector input connections • Two selectable 16 position safety obstruction sensors, auto adaptable to gate weight and size, for independent control of open and close cycles • Independent closing speeds for primary and secondary • Dual motor overcurrent safety shut off for additional protection • Two 7amp hour batteries provide 500 cycles in case of power failure with three modes of battery backup, open once, leave open or leave closed • On-board three button station • On-board UL reset button = Unique to Max SUPER ARM 1300 SECURITY SPECIFICATIONS • High traffic intuitive loop management system for exceptional security • Advanced security features with built-in audible and remote alarms • Magnetic lock control relay outputs with selectable delay times • Tamper alert relay output triggers “on” if gate is forced open • Audible alarm if gate is tampered with or ERD is triggered for heightened security • Steel cover with lock protects against intruders and vandalism • Gate disable feature disables all inputs with exception of the fire department and Max Open input for increased security • Built in transaction buffer • Gate status outputs for gate monitoring • Key activated jog function for emergency OPEN/CLOSE function • Advanced anti-tailgate feature prevents unwanted intrusion 3

• Supports >10,000 virtual transmitters Safety Loop close open JOG GATE OPEN / CLOSE RESET ALARM Moving Gate Can Cause Serious Injury or Death CLEAR! Gate may move at any time without prior warning. t let children operate the gate or play gate area. This entrance is for vehicles only. Pedestrians must use separate entrance. QUICK & RELIABLE APP COMMANDS: • App uses a dedicated cloud server to issue gate OPEN & other commands within a second. • Cellular data connectivity is more reliable than WiFi due to range limitations. • Cloud based app does not use text messaging which has unpredictable delays. Safety Loop close open JOG GATE OPEN / CLOSE RESET ALARM Moving Gate Can Cause Serious Injury or Death CLEAR! Gate may move at any time without prior warning. t let children operate the gate or play gate area. This entrance is for vehicles only. Pedestrians must use separate entrance. MANAGE GATE SITES USING MAX CLOUD APP: • Add Admin users that can manage the gate site database. • Add users with optional time restrictions • Issue temporary Guest Passes for visitors • With Max Keypad option: Program keypad keycodes, Wiegand keycodes for card readers, radio receivers and transponders with time restrictions • Setup Auto Open / Close Timer for Max operators • Retrieve Event log • Retrieve Operator Diagnostics info: Error log Safety Loop close open JOG GATE OPEN / CLOSE RESET ALARM Safety Loop close open JOG GATE OPEN / CLOSE RESET ALARM Moving Gate Can Cause Serious Injury or Death CLEAR! Gate may move at any time without prior warning. t let children operate the gate or play gate area. This entrance is for vehicles only. Pedestrians must use separate entrance. MULTIPLE GATE SITES SUPPORTED BY MAX CLOUD APP • Gate sites can be controlled and monitored individually via app SIMPLE AND SECURE APP LOGIN : • Securely login to app using Cloud based authentication code. This avoids the need to remember passwords USER FRIENDLY MENUS: • Easy to program App Users & Guest passes with time restrictions. All programming is done on Max Cloud App - not a website portal MAX CLOUD APP MAX CLOUD APP Affordable and unique APP control solution for the residential and commercial gate operator market. Compatible with Max Operators except Phantom F6 and 2000 Plus Smartphone · Tablet OPTIONAL Timers Diagnose Users Settings GATE STATUS: OPEN, OPENING, CLOSED CLOSE OPEN LAGUNA WOODS GATE GATE RELEASE

release. For emergency release unlock the key and lift up the hood. To engage the actuator, push down the hood and lock to resume automatic operation. The Max SUPER ARM 1300 ships with a heavy duty half inch stock rear bracket that is broached and welded. Both brackets front and rear, are silver zinc plated. P Front Bracket Rear Bracket MOUNTING BRACKETS 5 MECHANICAL RELEASE

SUPER ARM 1300 will collapse on impact when struck by vehicular traffic. When a vehicle hits a moving gate, to avoid damage to the actuators, the SUPER ARM 1300 reset automatically. VEHICLE HIT PROTECTION PUSH OPEN PULL OPEN INSIDE PROPERTY OUTSIDE PROPERTY TWO INSTALLATION OPTIONS OPEN OPEN CLOSED CLOSED 6

with the independent closing speeds adjusted the closing gate leaves can be synced ASYMMETRIC SPEED CONTROL For asymmetric installations, the two independent closing speeds can be adjusted to achieve a smooth closing sync. Whichever gate closes first, slow it down. This enables the installer to visually sync the closing cycle. This feature is unique to Maximum Control’s actuators. 7

Two 12V 7 AGM Batteries UL Reset Button Jog Open/Close Key Switch for emergency access to property Selectable Switch 115V or 230V AC 7 amp Fuse ON and OFF Power Supply Switch Two plugin power outlets Loop Rack Safety Loop Center Loop Exit Loop Steel housing 2- layer protection Gold zinc Electrostatic powder coating Gold plated automobile connectors throughout the system Control Panel The AC Control Box features a rugged metal construction that is gold zinc plated and powder coated for corrosion resistance. The Max AC Control Box comes with an exterior UL reset button, a convenient jog key switch for emergency access or egress, a 10 amp power supply with two 115 VAC accessory outlets, two 7 amp batteries conveniently located behind the control panel, a loop rack and much more. A lockable steel cover finishes off this slick design. A convenient LCD display keeps you informed. Functional data and error messages are visible when an accessory failure or function is present. This makes troubleshooting and monitoring a breeze. These many features can be explored in our downloadable installation manual available on max.us.com 8

Two 12V 18 Agm Batteries UL Reset Button Jog Switch input OPTIONAL ON and OFF Power Supply Switch 30A FUSE Loop Rack OPTIONAL Steel housing 2-layer protection Gold zinc Electrostatic powder coating Gold plated automobile connectors through the system Control Panel Solar Regulator 24V, 20A (MORNING STAR) Solar Regulator 24V, 20A (MORNING STAR) 9

2. Power/Solar Input 3. Module Port 4. Reset 5. UL Alarm 6. ID Plug 7. Loop Rack Input 8. 12VDC & 24VDC Limited Current Power Output 1. Battery Backup Mode Switch 2. Battery Test Switch 3. ERD Sensitivity 4. OBD Port 5. DIP Switches 6. Program Button 7. Loop Status 8. Solar Mode Application 9. Motion Control Buttons 10. Maglock Delay 11. LCD Display 12. Close Timer Switch 13. Jog Open/Close 14. Closing Gate Speed 8 7 6 5 3 4 2 1 CONTROL FEATURES AND CONNECTIONS 1 2 11 3 4 5 6 7 8 9 12 10 14 13 10

Two 12V 18 AH (AGM Rechargeable Batteries) UL Reset Button Jog Switch OPTIONAL 30A FUSE Loop Rack OPTIONAL Steel housing 2-layer protection Gold zinc Electrostatic powder coating Gold plated automobile connectors through the system SOLAR MODE Switch to enable low power draw for solar mode Control Panel Solar Regulator 24V, 10A (MORNING STAR) Solar Regulator 24V, 10A (MORNING STAR) 24V Solar Panel Output: 36 V (Max) - Open Circuit Wire solar panel terminals to solar regulator input Caution: polarity matters Solar Panel POWE SOLAR Neg ON and OFF Power Supply Switch

The map and daily cycle rate shown are approximations based upon the average solar radiation and the temperature effects on batteries in the given regions. Local geography and weather conditions may require additional solar panels. USE LOW POWER accessories in order to minimize power draw. Each additional accessory draws power affecting the daily cycle rate. Select proper solar panel and battery size 1 33Ah 33Ah batteries 50Ah 33Ah 50Ah 50Ah batteries batteries batteries batteries batteries 19 20 11 12 4 5 50 20 16 17 8 9 2 2 100 14 16 7 8 1 1 200 9 10 2 3 #NUM! #NUM! 250 50 20 100 200 250 50 20 100 200 250 4 5 #NUM! #NUM! #NUM! #NUM! 97 173 58 105 24 44 92 169 54 101 21 41 90 59 166 53 99 19 39 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) 60W* Solar Panel NOTE: Must Use 24V Solar Panel 85W* Solar Panel NOTE: Must Use 24V Solar Panel Total System Current Draw (mA) 173 58 105 24 44 169 54 101 21 41 166 53 99 19 39 131 131 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! 120W* Solar Panel NOTE: Must Use 24V Solar Panel MEGATRON PRO GATE WEIGHT LESS THAN 1000 LBS batteries batteries batteries batteries batteries batteries 5 19 20 11 12 4 5 15 16 17 8 9 2 2 20 14 16 7 8 1 1 40 9 10 2 3 #NUM! #NUM! 60 4 5 #NUM! #NUM! #NUM! #NUM! 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) 60W* Solar Panel NOTE: Must Use 24V Solar Panel 85W* Solar Panel NOTE: Must Use 24V Solar Panel Total System Current Draw (mA) 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! 120W* Solar Panel NOTE: Must Use 24V Solar Panel MEGATRON PRO HEAVY GATE WEIGHT GREATER THAN 1000 LBS (LESS THAN MAX WEIGHT) SWING PRO OPERATORS 33Ah 33Ah 50Ah 33Ah 50Ah 50Ah 92 97 90 59 The map and daily cycle rate shown are approximations based upon the average solar radiation and the temperature effects on batteries in the given regions. Local geography and weather conditions may require additional solar panels. USE LOW POWER accessories in order to minimize power draw. Each additional accessory draws power affecting the daily cycle rate. 33Ah 33Ah batteries 50Ah 33Ah 50Ah 50Ah batteries batteries batteries batteries batteries 19 20 11 12 4 5 50 20 16 17 8 9 2 2 100 14 16 7 8 1 1 200 9 10 2 3 #NUM! #NUM! 250 50 20 100 200 250 50 20 100 200 250 4 5 #NUM! #NUM! #NUM! #NUM! 97 173 58 105 24 44 92 169 54 101 21 41 90 59 166 53 99 19 39 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) Solar Panel Must Use 24V ar Panel Solar Panel Must Use 24V ar Panel Total System Current Draw (mA) 173 58 105 24 44 169 54 101 21 41 166 53 99 19 39 131 131 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! Solar Panel Must Use 24V ar Panel MEGATRON PRO GATE WEIGHT LESS THAN 1000 LBS batteries batteries batteries batteries batteries batteries 5 19 20 11 12 4 5 15 16 17 8 9 2 2 20 14 16 7 8 1 1 40 9 10 2 3 #NUM! #NUM! 60 4 5 #NUM! #NUM! #NUM! #NUM! 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) Solar Panel Must Use 24V ar Panel Solar Panel Must Use 24V ar Panel Total System Current Draw (mA) 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! Solar Panel Must Use 24V ar Panel MEGATRON PRO EAVY GATE WEIGHT GREATER THAN 1000 LBS (LESS THAN MAX WEIGHT) 33Ah 33Ah 50Ah 33Ah 50Ah 50Ah 92 97 90 59 The map and daily cycle rate shown are approximations based upon the average solar radiation and the temperature effects on batteries in the given regions. Local geography and weather conditions may require additional solar panels. USE LOW POWER accessories in order to minimize power draw. Each additional accessory draws power affecting the daily cycle rate. 33Ah 33Ah batteries 50Ah 33Ah 50Ah 50Ah batteries batteries batteries batteries batteries 19 20 11 12 4 5 50 20 16 17 8 9 2 2 100 14 16 7 8 1 1 200 9 10 2 3 #NUM! #NUM! 250 50 20 100 200 250 50 20 100 200 250 4 5 #NUM! #NUM! #NUM! #NUM! 97 173 58 105 24 44 92 169 54 101 21 41 90 59 166 53 99 19 39 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) 60W* Solar Panel NOTE: Must Use 24V Solar Panel 85W* Solar Panel NOTE: Must Use 24V Solar Panel Total System Current Draw (mA) 173 58 105 24 44 169 54 101 21 41 166 53 99 19 39 131 131 25 67 #NUM! 13 68 #NUM! 14 #NUM! #NUM! 120W* Solar Panel NOTE: Must Use 24V Solar Panel MEGATRON PRO GATE WEIGHT LESS THAN 1000 LBS batteries batteries batteries batteries batteries batteries 5 19 20 11 12 4 5 15 16 17 8 9 2 2 20 14 16 7 8 1 1 40 9 10 2 3 #NUM! #NUM! 60 4 5 #NUM! #NUM! #NUM! #NUM! 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! Gate solar cycles per day Zone 1 (6 Hrs Sunlight/Day) Zone 2 (4 Hrs Sunlight/Day) Zone 3 (2 Hrs Sunlight/Day) 60W* Solar Panel NOTE: Must Use 24V Solar Panel 85W* Solar Panel NOTE: Must Use 24V Solar Panel Total System Current Draw (mA) 5 97 173 58 105 24 44 15 92 169 54 101 21 41 20 90 166 53 99 19 39 100 59 131 25 67 #NUM! 13 250 9 68 #NUM! 14 #NUM! #NUM! 120W* Solar Panel NOTE: Must Use 24V Solar Panel MEGATRON PRO HEAVY GATE WEIGHT GREATER THAN 1000 LBS (LESS THAN MAX WEIGHT) SWING PRO OPERATORS 33Ah 33Ah 50Ah 33Ah 50Ah 50Ah 92 97 90 59 SWING, ACTUATOR ACTUATOR GATE SOLAR CYCLES PER DAY ZONE 1 (6 Hrs Sunlight/Day) ZONE 2 (4 Hrs Sunlight/Day) ZONE 3 (2 Hrs Sunlight/Day) PANEL SIZE Total System Current Draw (mA) 18Ah BATTERIES 18Ah BATTERIES 18Ah BATTERIES 60 W 26 442.74 438.58 338.38 50 408.16 400.16 296.12 100 336.13 320.13 208.08 200 192.08 160.06 32.01 250 120.05 80.03 -56.02 85 W 26 442.74 438.58 434.41 50 408.16 400.16 392.16 100 336.13 320.13 304.12 200 192.08 160.06 128.05 250 120.05 80.03 40.02 120 W 26 442.74 438.58 434.41 50 408.16 400.16 392.16 100 336.13 320.13 304.12 200 192.08 160.06 128.05 250 120.05 80.03 40.02 200 W 26 442.74 438.58 434.41 50 408.16 400.16 392.16 100 336.13 320.13 304.12 200 192.08 160.06 128.05 250 120.05 80.03 40.02

Super Arm protects all peripheral inputs, loop inputs, power inputs, relay outputs, and all communication lines (over 35 channels of protection) in 1/1,000,000,000 of a second. With special emphasis on power supply protection, the Max SUPER ARM 1300 is guaranteed to withstand any lightning hit more than 50 feet away. Truly protected like no other operator in the world. 50 FEET 50 FEET 50 FEET 50 FEET 13

MAX WARRANTY 2-Year Warranty or 100,000 Cycles whichever comes first Maximum Controls LLC Warranty and Return Policy Section I Coverage a. 2 years or 100,000 cycles whichever comes first on components b. 1 year on batteries Section II Not Covered a. Damages due to flooding b. Damages due to fire c. Damages due to negligence i.e. leaving the cover off in the rain, improper wiring of AC or peripheral systems d. Damages due to product misuse i.e. gate and operator combination mismatch e. Damages due to vandalism Section III RMA Shipping Policy a. Maximum Controls LLC will pay for return shipping via standard ground UPS or USPS FOB CA on all RMA’s within one year of Distributor’s purchase b. Any form of “Expedited Shipping” on any RMA will be paid by Distributor Section IV Product Returns a Products must be in original, resalable condition with all warranty information, manuals, and original packaging. b. A re-stock fee of 10% will be charged on all returned products. c. All returned products must reference a Maximum Controls PRA number or it will be refused. d. Maximum Controls is not responsible for freight charges associated with returned merchandise. 14

949.699.0220 10530 Lawson River Ave. Fountain Valley CA 92708 USA Independent Dealer or Distributor www.Max.US.com DSP Control AC AC control control box box MADE IN USA MAX MAX SUPER ARM SUPER ARM 1300 1300 MADE IN GERMANY