Honeywell TRADELINE HE360 Installation Instructions Manual

Copyright © 2001 Honeywell • •All Rights Reserved INSTALLATION INSTRUCTIONS 69-1572 HE360 Humidifier Installation Kit WELCOME To the comfortable world of humidified air. When you use your Honeywell humidifier, you notice that your skin is not as dry, and that your scratchy throat and irritated nasal passages that aggravat ...

69-1572 2 • Allow adequate clearance in front of and above the humidifier so you can easily remove the cover to perform routine maintenance. — Mount the humidifier at least 3 in. (78 mm) above the furnace body to allow adequate space for the solenoid valve and drain line. — Mount the humidifier in a conditioned space t ...

3 69-1572 4. Tape the template in position and trace around the template. 5. Remove the template and carefully cut the rectan- gular opening. 6. Disassemble the humidifier; remove the cover and take out the humidifier pad assembly. See Fig. 3. Fig. 3. Disassembling humidifier. 7. Make sure the humidifier housing is level, th ...

69-1572 4 d. Insert the tubing into the solenoid valve fitting and support the valve while tightening the com- pression nut. NOTE: Do not over-tighten the compression nut. Mod- erate tightness prevents leaking. e. Repeat steps a. through d. for solenoid valve fitting. f. Secure tubing with clamps provided. Fig. 6. Installing ...

5 69-1572 Fig. 9. Attaching sail to switch. 5. Press together the sides of the wire loop. Insert the sail into the duct. (When in the Off position, the sail should point into the direction of airflow as shown in Fig.10.) Fig. 10. Inserting sail switch in direction of airflow. 6. Secure the switch by using the sheet metal scr ...

69-1572 6 1. Run the two-strand thermostat wire from the humidifier to the humidistat, and from the humidis- tat to the sail switch. 2. Cut lengths of thermostat wire to reach between components, leaving adequate wire at both ends for connections. NOTE: Humidistat and sail switch can be wired in any order. 3. At the humidifi ...

7 69-1572 TROUBLESHOOTING YOUR HUMIDIFIER (TABLE 2) Table 2. Troubleshooting Humidifier. Problem What to look for What to do Water leakage Leaking joints. Shut off water. Tighten connections. Brass tubing inserts Verify that brass tubing inserts are used. Saddle valve leaking. Verify rubber pad is installed on saddle valve. ...

www.honeywell.com/yourhome HE360 HUMIDIFIER INSTALLATION KIT Printed in U.S.A. on recycled paper containing at least 10% post-consumer paper fibers. Home and Building Control Home and Building Control Honeywell Honeywell Limited-Honeywell Limitée 1985 Douglas Drive North 35 Dynamic Drive Golden Valley, MN 55422 Scarborough, Ontario M1V ...