ClearSpan Pro Solar Star R030 Instruction Manual

©2010 ClearSpan™ All Rights Reserved. Reproduction is prohibited without permission. STK# DIMENSIONS R030 30' W x L (length varies) R035 35' W x L (length varies) ClearSpan™ Pro Solar Star™ Greenhouses Photo may show a building of a different length. Frame is shown with a roll-up side option and customer-su ...

Table of Contents READ THIS BEFORE YOU BEGIN The main building and any accessory (end wall, door, etc.) requires a specific installation sequence. All buildings include an instruction guide; each accessory includes an instruction guide. Near the beginning of each instruction guide (building or accessory), you will find information t ...

Important Information YOU MUST READ THIS DOCUMENT BEFORE YOU BEGIN TO ASSEMBLE THE SHELTER. Thank you for purchasing this ClearSpan™ greenhouse. When properly assembled and maintained, this product will provide years of reliable service. These instructions include helpful hints and important information needed to safely assemble a ...

Important Information ASSEMBLY PROCEDURE Following the instructions as presented will help ensure the proper assembly of your structure. Failing to follow these steps may result in an improperly assembled and anchored structure and will void all warranty and protection the owner is entitled. The steps outlining the assembly process ...

Important Information REQUIRED TOOLS The following list identifies the main tools needed to assemble the shelter. Additional tools and supports may be needed depending on the structure, location, and application. Tape measure or measuring device and marker to mark • locations on the pipes and rafters Variable speed drill and impac ...

Important Information Ground Level Inside of Shelter Outside of Shelter BASEBOARD NOTE A customer-supplied baseboard and retaining board are required to attach the drop-down side panels. The baseboard is optional but recommended for a building with a roll-up side. See the exploded view below. The baseboard runs the length of the fra ...

Parts Identification 102197 Aluminum U-Channel (drop-down sides only) 104211 Aluminum U-Channel (roll-up sides only) 103544 Mounting Plate AS5020 Pulley FA2155 and FA1960 Eye Screw 104189 Turnbuckle FA4482B Tek Screw FAG304B 1/4" x 1" Hex Bolt FALB01B 1/4" Zinc Nut FAG361B 3/8" x 2-1/2" Hex Bolt FAME08B 3/8" Flat washer FALB04B 3/8 ...

ClearSpan™ Pro Solar Star™ Greenhouses Overview Ground Level Customer-Supplied Baseboards End Rafter Interior Rafter Ridge Purlin Under Purlin Cable Strut Ground Post On-center Drawing may show a model of a different length. Refer to Quick Start section located in the back of these instructions for on-center measurements and pos ...

Prepare and Square the Building Site PREPARE THE BUILDING SITE A level site is required to accurately and safely construct the building. Consult the services of a qualified contractor to properly grade and prepare the site. Site should slope away from the building to allow water to properly drain away from the assembled building. Af ...

Set the Ground Posts (option) on-center on-center on-center on-center Drawing may show layout of a different length. Refer to Quick Start section located in the back of these instructions for on-center measurements and post layout for your frame. ATTENTION: Set another string line (not shown) to mark the uniform height of all main ...